Lubrication Intervals - Yamaha XZ550RJ Service Manual

LUBRICATION INTERVALS
Type
Initial
Item Remarks
(Recommended lubricants)
500 1300) 1,500 11,000)
Engine oil
Replace/Warm engine before
See page 2-23
0
draining
Oil filter
Replace/ After installing start
- 0
engine check oil leaks
Final gear oil
Replace
SAE 80 API GL-4 Hypoid gear oil
0
Hydraulic brake fluid
reserve
Use new fluid only
OOT#3 check
Control/Meter cables Apply thoroughly SAE 10W 30 motor oil
Throttle grip/Housing Apply lightly Lithium base
0
Rear arm pivot bearing Apply grease fully or yearly Medium-weight wheel bearing grease
Brake pedal shaft
Apply lightly
SAE 10W 30 motor oil
Change pedal shaft/brake
Apply lightly SAE 10W 30 motor oil
and clutch lever pivot
Center and side stand
Apply lightly SAE 10W 30 motor oil
pivots
Front forks
Drain completely/Replace -
SAE 10W 30 type SE motor oil
Check specifications
Steering bearins
Inspect thoroughly/Pack
Medium-weight wheel bearing grease
moderately
Speedometer gear hosing
Inspect thoroughly/Pack
Litium base grease
moderately
Coolant
Replace
See page 2-27
NOTE: _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _
Brake flu id replacement:
1. When disassembling the master cylinder or caliper cylinder, replace the brake fluid.
Normally check the brake fluid level and add the fluid as required.
2. On the inner parts of the master cylinder and caliper cylinder, replace the oil seals every two
years.
3. Replace the brake hoses every four years, or if cracked or damaged.
2-2
check
0
Unit· km {miles)
Thereafter every
3,000 12,000) 3,000 12,000) 6,000 14,000)
0
5,000 13,000)
5,000 13,000) 10,000 16,000)
10,000 16,000)
check
check
0 0
0
0
12,000 18,000)
0 0
0 0
0 0
0
0
check 12 ,OOO 18 ,OOO I
12 ,OOO 18 ,OOO I
Every two years