Removing And Installing Charge Pressure Sender G31 - Seat Ateca 2017 Workshop Manual

Ateca 2017 ➤ , León 2013 ➤ , León ST 2013 ➤
4 cyl. petrol engine (1.8 l and 2.0 l with direct injection, 4 V, exhaust gas turbocharger, timing chain,
EA 888 III. Gen) - Edition 10.2018
Vehicles with bearing support for charge-air cooler, bolted.
– Use bolts to secure radiator mountings, whose fasteners have
been pinched off, to lock carrier. Screws -2- ⇒ ETKA (elec‐
tronic spare parts catalogue) .
• Tightening torque: 5 Nm
Continued for all vehicles
– Install lower air ducts on both sides from lock carrier.
– Install radiator cowl
– Fit charge air hose connections
– Connect coolant hose with plug-in connector
– Install headlight ⇒ Electrical system; Rep. gr. 94 ; Removing
and installing headlights .
– Install front bumper cover ⇒ General body repairs, exterior;
Rep. gr. 63 ; Front bumper; Removing and installing front
bumper .
– Replenish coolant ⇒ page 244
Note
Hose connections and hoses for charge air system must be
♦
free of oil and grease before assembly.
Secure all hose connections with the correct type of hose clips
♦
(same as original equipment) ⇒ Electronic parts catalogue
(ETKA) .
To ensure that the charge air hoses can be properly secured
♦
at their connections, spray rust remover onto the worm thread
of used hose clips before installing.
Specified torques
♦ ⇒ "4.1 Exploded view - radiator/radiator fans", page 291
♦ ⇒ "4.3 Exploded view - radiator cowl and radiator fans",
page 295
♦ ⇒ "2.1 Assembly overview - charge air system", page 319
2.4 Removing and installing charge pres‐
sure sender - G31-
Removing
– Remove noise insulation ⇒ General body repairs, exterior;
Rep. gr. 66 ; Noise insulation; Assembly overview - noise in‐
sulation .
326
Rep. gr.21 - Turbocharging/supercharging
⇒ page 300 .
⇒ page 321
.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by SEAT S.A. SEAT S.A does not guarantee or accept any liability with
respect to the correctness of information in this document. Copyright by SEAT S.A.
⇒ page 292 .