Seat Ateca 2017 Workshop Manual page 220

Ateca 2017 ➤ , León 2013 ➤ , León ST 2013 ➤
4 cyl. petrol engine (1.8 l and 2.0 l with direct injection, 4 V, exhaust gas turbocharger, timing chain,
EA 888 III. Gen) - Edition 10.2018
– Apply silicone sealant between cylinder block and lower timing
chain cover, as shown in illustration -arrows-.
Note
The sump (top section) must be installed within 5 minutes after
♦
applying the silicone sealant.
The line of sealant must not be thicker than prescribed, as
♦
otherwise excessive sealant will enter the sump and obstruct
the strainer in the oil intake pipe.
• Sump (top section) and crankcase must be flush at gearbox
end.
– Immediately fit top section of sump, and turn in bolts as far as
stop.
– Tighten oil sump upper part with 14 bolts. Specified torque
⇒ Fig. ""Oil sump upper part 14 bolts - torque and tightening
sequence"" , page 202
– Tighten oil sump upper part with 18 bolts. Specified torque
⇒ Fig. ""Oil sump upper part 18 bolts - torque and tightening
sequence"" , page 203
– Fit bolts -arrows-. Specified torque: 8 Nm + 45°
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
– Tighten new bolts -arrows-.
permitted unless authorised by SEAT S.A. SEAT S.A does not guarantee or accept any liability with
respect to the correctness of information in this document. Copyright by SEAT S.A.
Component
Bolts -arrows-
– Install rear sealing flange
– Fit the oil pump ⇒ page 213
– Fit new baffle plate and secure in position.
– Install sump (bottom section)
– Install windscreen washer tank ⇒ Electrical system; Rep. gr.
92 ; Windscreen washer system; Overview - windscreen
washer system .
Further assembly is basically the reverse of the dismantling se‐
quence.
– Replenish engine oil and check oil level ⇒ Maintenance ;
Booklet 501 ; Engine oil: Draining; Renewing oil filter and re‐
plenishing engine oil .
Specified torques
♦ ⇒ "1.1 Exploded view - sump/oil pump", page 200
212
Rep. gr.17 - Lubrication
Tightening torque
8 Nm +45°
⇒ page 75 .
.
⇒ page 203 .