Toyota Celica 2005 Repair Manual page 2060

SR−14
ACC
A
B
2005 CELICA (RM1131U)
STEERING
F08842
F08859
Matchmarks
F08844
Matchmarks
F08846
− TILT STEERING COLUMN
6. REMOVE COLUMN UPPER AND LOWER COVERS
Remove the 3 screws, column upper and lower covers.
7. REMOVE SPIRAL CABLE, LIGHT CONTROL SWITCH
AND HEADLIGHT DIMMER SWITCH AND WIPER AND
WASHER SWITCH
(a) Disconnect the 3 connectors from the spiral cable, light
control switch and headlight dimmer switch and wiper and
washer switch.
(b) Disconnect the airbag connector from the spiral cable.
(c) Push the claw and pull out the light control switch and
headlight dimmer switch.
(d) Employ the same manner described above to the wiper
and washer switch.
(e) Remove the spiral cable.
NOTICE:
Do not disassemble the spiral cable or apply oil to it.
8. A/T:
REMOVE KEY INTERLOCK CABLE
With the key in ACC, push the claw and pull out the key interlock
cable.
9. REMOVE COLUMN HOLE COVER SILENCER SHEET
10. DISCONNECT NO. 2 INTERMEDIATE SHAFT AS-
SEMBLY
(a) Place matchmarks on the No. 2 intermediate shaft as-
sembly and intermediate extension.
(b) Loosen the bolt A and remove the bolt B, then disconnect
the No. 2 intermediate shaft assembly.
11. REMOVE STEERING COLUMN ASSEMBLY
(a) Disconnect the connectors.
(b) Remove the 2 bolts, nuts and steering column assembly.
12. REMOVE NO. 2 INTERMEDIATE SHAFT ASSEMBLY
(a) Place matchmarks on the No. 2 intermediate shaft as-
sembly and main shaft assembly.
(b) Remove the bolt and No. 2 intermediate shaft assembly.
2059