Toyota Celica 2005 Repair Manual page 2324

BO−18
b
b
a a
a − a
2005 CELICA (RM1131U)
INSPECTION
INSPECT FRONT DOOR GLASS
Check the following. If the conditions are not met, readjust the
glass.
c
c
3.5 mm (0.138 in.)
7.5 mm (0.295 in.)
15.2 ± 3.0 mm (0.598 ± 0.118 in.)
BODY − FRONT DOOR
(1) When you close the door with the glass fully closed,
the a−a, b−b, c−c sections are in the same condition
as shown in the illustration.
(2) When you close the door with the glass fully closed,
check that the weatherstrip is not pinched and that
the door glass is not in contact with the roof drip
moulding.
(3) When the door glass is fully closed, check that the
outside edge of the door glass is in contact with the
weatherstrip at the front pillar and roof side and that
the edge of the glass cannot be seen.
(4) Check that the door glass is not loose when it is half
open.
(5) When the door glass is rising up, check that the door
glass and roof side weatherstrip are parallel and
that the door glass contacts the 2 upper stops.
(6) Check that the door glass moves up and down
smoothly over all areas.
0 − 1.5 mm (0 − 0.059 in.)
b − b
2323
c − c
2.3 mm
(0.0906 in.)
13.3 ± 3.0 mm
(0.524 ± 0.118 in.)
BO1DL−07
H12651