Subaru IMPREZA GD 2007 Series Manual page 3403

asieps_tobira_IM_US.book 7 ページ ２０１２年１月１７日 火曜日 午後３時４８分
B: INSTALLATION
CAUTION:
Be sure the lining surface is free from oil and
grease.
1) Apply brake grease to the following locations.
Brake grease:
Brake Grease (Part No. 003602002)
• Six contact surfaces of the shoe rim and back
plate gasket
• Contact surface of the shoe wave and the anchor
pin
• Contact surface of the lever and strut
• Contact surface of the shoe wave and the adjust-
er assembly
• Contact surface of the shoe wave and the strut
• Contact surface of the lever and the shoe wave
2) Insert the primary side brake shoe into the an-
chor pin groove.
3) Secure the brake shoe with the shoe hold-down
pin and cup.
4) Install the plate to the anchor pin, then install the
primary return spring.
(1)
(4)
(5)
(1) Primary return spring
(2) Anchor pin
(3) Shoe guide plate
(4) Primary shoe
(5) Shoe hold-down pin & cup
5) Install the parking brake cable to the lever.
6) Install the strut and adjuster, then secure the
secondary side brake shoe with the shoe hold-
down pin and cup.
Parking Brake Assembly (Rear Disc Brake)
(2)
(3)
PB-00039
PB-7
NOTE:
• Install the strut spring of both right and left wheel
facing vehicle front.
• Install the adjuster assembly with screw section
on the left side.
(1) LH
7) Install the secondary return spring and the ad-
justing spring.
(1)
(2)
(8)
(1) Lever
(2) Secondary brake shoe
(3) Strut spring
(4) Strut
(5) Return spring
(6) Adjuster
(7) Shoe hold-down cup
(8) Adjusting spring
8) Adjust the parking brake. <Ref. to PB-8, AD-
JUSTMENT, Parking Brake Assembly (Rear Disc
Brake).>
9) Drive the vehicle to break-in the parking brake
lining.
(1) Drive the vehicle at about 35 km/h (22
MPH).
(2) With the parking brake release button
pushed in, pull the parking brake lever gently.
(3) Drive the vehicle for about 200 m (0.12 mile)
in this condition.
(4) Wait 5 to 10 minutes for the parking brake to
cool down. Repeat this procedure once more.
(5) After breaking-in, re-adjust the parking
brakes.
PARKING BRAKE
PB-00016
(4)
(3)
(5)
(7)
(6)
PB-00017