Battery; Battery Specifications; General Battery Information - Polaris RZR XP 1000 Service Manual

BATTERY

Battery Specifications

Polaris / Johnson Controls 575
Type
Sealed - Maintenance Free
Voltage
12 Vdc
Nominal Capacity
30 AH
@ 10 HR Rate
CCA 575
Nominal Open
12.8 Vdc or more.
Circuit Voltage
Recommended
1.8A @ 5-10 HR or 6.0A @ 1
Charging Rate
HR
NOTE: Never attempt to open the battery. If the seal
is broken, the battery will be ruined and will fail
within a few weeks.
9925724 R01 - 2014-2015 RZR XP 1000 / RZR XP4 1000 Service Manual

General Battery Information

accessories contain lead and lead compounds, and
cause cancer and birth defects or other reproductive
Serious burns can result from contact with the skin,
Internal: Drink large quantities of water or milk. Follow
with milk of magnesia, beaten egg, or vegetable oil. Call
Eyes: Flush with water for 15 minutes and get prompt
Batteries produce explosive gases. Keep sparks, flame,
cigarettes, etc. away. Ventilate when charging or using
in closed space. Always shield eyes when working near
1. Check battery voltage with a volt/ohm meter. A fully
2. If the voltage is below 12.6 V, the battery will need to
3. Remove battery from the vehicle (see Chapter 2 –
4. Test battery with a voltage meter or load tester to
5. Charge the battery as recommended (see Chapter
© Copyright 2014 Polaris Industries Inc.
WARNING
CALIFORNIA PROPOSITION 65 WARNING:
Batteries, battery posts, terminals and related
other chemicals known to the State of California to
harm. WASH HANDS AFTER HANDLING.
WARNING
Battery electrolyte is poisonous. It contains acid!
eyes, or clothing.
ANTIDOTE:
External: Flush with water.
a physician immediately.
medical attention.
batteries.
Keep out of reach of children.
charged battery should be 12.8 V or higher.
be recharged (see Chapter 11 –
Procedure , page 11.37).
To service a Maintenance Free battery:
Battery Removal, page 2.34).
determine battery condition. This will determine the
length of time required to charge the battery to full
capacity. Refer to OCV table (see
Circuit Voltage Test, page 11.36).
11 – Charging Procedure , page 11.37).
ELECTRICAL
Charging
11
OCV - Open
11.35