Triumph TR6 PI Operation Manual page 490

STARTER MOTOR - TYPE 2MlOO PE
Data and description
86.60.00
ELECTRICAL
Note that two starter motors have been fitted to the
TR6 model range. Ensure that information obtained from
this manual refers to the appropriate starter motor for the
specific vehicle. A Lucas type M418G PE unit was fitted up
to engine numbers CP 53636 and CC 63894. A Lucas type
2MlOO PE unit was fitted from engine numbers CP 53637
and CC 63895.
Data
Manufacturer
Type
Lucas part No.
Stanpart No.
Motor
Yoke diameter
Light running - speed
current
torque
Load running - speed
current
torque
Locked - speed
current
torque
Commutator minimum skimming thickness
Brush length - new
renew if less than
Brush spring tension
Shaft end-float: maximum between bush and spire
retaining ring
Bearing renewal mandrel diameter:
Commutator end cover bearing
Drive end bracket bearing
Solenoid
Pull-in winding resistance - measured between un-
marked 'WR wire' connector and 'STA' terminal
Hold-in winding resistance - measured between un-
marked 'WR wire' connector and unit body
Triumph TR6 Manual. Part No. .545277 Issue J
Lucas
2MlOO PE
25647
218053
4 in (101 ·60 mm)
6,000 rev/min
40 amp
Not stated
1,000 rev/min
300 amp
7'3 lbf ft (I'OJ kgf m)
Nil
463 amp
14'41bf ft (1"99 kg[ m)
0'140 in (3·56 mm)
0·710 in (18"03 mm)
0'375 in (9·53 mm)
36 ozf (1000 gt)
0"010 in (0·25 mm)
0·4377 in (11'118 mm)
0·4729 in (12·012 mm)
0'25 to 0'27 ohm
0·76 to 0'80 ohm
86.60.00 Sheet 4