Triumph TR6 PI Operation Manual page 100

ENGINE
NOTE: The following instructions, 96 to 99, relate to the
carburetter engine.
98. Establish the distributor drive shaft end-float
~
instructions 8 to 12, 12.10.22. (Carburetter engine).
99. Turn the crankshaft until number one and six pistons
are at T.D.C. with number one firing.
100. Fit the distributor drive gear with the offset slot in
the position illustrated.
101. Fit and secure the pedestal with the two nuts and
washers.
102. Fit the ignition distributor leaving the clamp bolt
slack until the ignition is timed when the engine is
refitted to the car.
103. Fit the front and rear lifting eyes.
104. Fit the exhaust manifQld and gasket.
105. Fit the inlet manifold complete with carburetters or
106. Fit the P.I. inlet manifold.
107. Connect .the injector pipes to their respective
injectors ~ P.l. only.
108. Connect the vacuum hose from the metering unit to
the inlet manifold - P.I. only.
109. Fit the air intake manifold SUppO.l<t bracket - P.l.
only.
110. Fit the mechanical fuel pump and delivering pipe to
the carburetters.
Ill. Fit the water pump complete with its housing
instructions II to 14,26.50.63.
112. Fit the clutch assembly, instructions 4 to 7, 33.10.01.
113. Fit the starter motor.
**
114. Fit the ignition coil and earth strap and (later USA
market engines only) the ignition suppressor.
**
115. Fit the alternator and drive belt and adjust the belt
tension.
116. Fit the engine mounting brackets.
117. Fit the fan blades.
118. Fit the gearbox to the engine.
119. Re-fit the engine and gearbox assembly to the car
ensuring:-
a. The engine sump is replenished with new oil of
the correct grade to the high mark on the
dipstick.
b. The gear box oil level is checked.
c. The cooling system is re-filled.
120. Time the ignition 86.35.15.
121. Tune and adjust the carburetters 19.15.02, or check
and adjust the·butterflies - P.I. engines 19.20.05.
122. Check the engine and cooling system for oil and
water leaks.
12.41.05 Sheet 8
Triumph TRtl Manual. Part No. 545277 Jssue 2