Throttle Cable Adjustment - BRP Cam-am Outlander 6x6 DPS 2015 Manual

Firmly push injector until it bottoms out.
Reinstall fuel rail.
FUEL RAIL
Fuel Rail Replacement
Fuel Rail Removal
1. Disconnect fuel line to reach the rear injector.
FUEL TANK AND FUEL PUMP
Refer to
tion.
2. Unscrew rail retaining screws.
3. Gently pull rail off by hand.
vmr2006-014-073_a
TYPICAL
To disconnect fuel rail from hose, cut clamp on
fuel hose using
OETIKER PLIERS (P/N 295 000 070)
FUEL TANK AND FUEL PUMP
Refer to
removal/installation procedures.
NOTE: If fuel rail is removed for access to fuel in-
jector, it is not necessary to cut hose clamp. Only
to replace fuel rail.
Fuel Rail Installation
For installation, reverse the removal process how-
ever, pay attention to the following.
Install new clamps using pliers as per removal (if
fuel rail was replaced).
Install fuel rail and evenly tighten screws a little at
a time each side.
FUEL RAIL INSTALLATION
INJECTOR O-RINGS
NEW
(Lubricate with engine oil)
vmr2015-129
Subsection 01 (ELECTRONIC FUEL INJECTION (EFI))
subsec-
.
for clamp
RETAINING SCREW
TORQUE
10 N•m ± 1 N•m
(89 lbf•in ± 9 lbf•in)
Section 04 FUEL SYSTEM
NOTE: Activate fuel pump a few times to built
fuel pressure.
WARNING
Perform a fuel pressure test and ensure that
there is no leak. Refer to
FUEL PUMP
.
THROTTLE CABLE
Throttle Cable Removal
Remove steering cover.
Remove LH side panel.
Disconnect throttle cable from throttle body. Re-
fer to procedure in this subsection.
Disconnect throttle cable from throttle lever.
Remove throttle cable.
Throttle Cable Installation
Reverse removal procedure.
Proceed with

THROTTLE CABLE ADJUSTMENT

in this subsection.
Throttle Cable Adjustment
Mechanically adjust the throttle cable as follows.
Handlebar and throttle cable must be at their
normal position. Throttle cable routing must have
been performed before adjusting cable.
Activate throttle lever a few times. Make sure
throttle cam of throttle body rests against set
screw without any tension in the cable.
vmr2006-014-064_b
1. Contact here
2. Free-play here
FUEL TANK AND
377