Daihatsu 1997 Terios J100 Service Manual page 334

CH–22
SERVICE SPECIFICATIONS
Battery specific gravity (Except Delco Freedom battery)
Alternator:
50A (For manual transmission vehicles)
Alternator:
55A (For automatic transmission vehicles)
TROUBLE SHOOTING
Problem
Charge warning lamp will not
glow even if ignition switch is
turned ON.
Charge warning lamp will not
go out even if engine has
started.
TO INDEX
Rated output
Rotor coil resistance
Slip ring diameter
Brush exposed length
IC regulating voltage
Rated output
Rotor coil resistance
Slip ring diameter
Brush exposed length
IC regulating voltage
Possible causes
Fuse blown
Lamp bulb burnt
Poor connection of wiring
Drive belt loose or worn
Battery cables loose, corroded
or worn
Fuse blown
Fusible link blown
IC regulator or alternator faulty
Wiring faulty
1.25 - 1.27
Amperage 50A
2.9 Ω at 20ϒC (68ϒF)
Resistance
Standard 14.4 mm
Minimum 14.0 mm
Standard
10.5 mm
Minimum 8.4 mm
Hi level 14.1 - 15.2 volts
55A
Amperage
2.9 Ω at 20ϒC (68ϒF)
Resistance
14.4 mm
Standard
14.0 mm
Minimum
10.5 mm
Standard
8.4 mm
Minimum
14.1 - 15.2 volts
Hi level
Remedies
Check gauge fuse.
Replace bulb.
Repair poor connection of wiring.
Repair or replace.
Replace regulator assembly.
Adjust or replace.
Repair or replace cables.
Check gauge fuse.
Replace fusible link.
Check charging system.
Repair or Replace.
TO NEXT SECTION
JCH00075-00000
Page
BE–6
BE Section
BE Section
CH–3
MA–6
CH–3
JCH00076-00000