Table of Contents
Advertisement
PRECAUTIONS
1. Prior to the inspection, make sure that the battery cables are connected securely.
2. When a quick charging operation is carried out, first be sure to disconnect the battery cables.
3. Never use a high-voltage insulation resistance tester for the purpose of conducting this inspection.
4. Under no circumstances should the battery cables be disconnected while the engine is rotating.
IN-VEHICLE INSPECTION
1. Inspection of battery
<Reference>
•
First-aid treatment for dilute sulfuric acid
Nature of accident
Acid gets to vehicle body.
* Acid gets into your eyes.
* Acid gets to your skin or clothes.
Acid is spilled.
* Acid is swallowed.
* After the aforesaid first-aid treatment has been done, call a physician immediately.
2. Inspection of drive belt
(Refer to the MA section of the service manual.)
3. Check of fuses for continuity
Fusible link
Fusible link block
EFI No. 1 fuse
Engine fuse
Gauge fuse
4. Checking alternator wiring and listening for abnormal nois-
es
(1) Check to see if the alternator wire is connected prop-
erly to the alternator.
(2) Ensure that the alternator emits no abnormal noise
while the engine is running.
5. Check of charge warning lamp circuit
(1) Turn OFF all accessory switches.
(2) Start the engine and warm up the engine thoroughly.
Turn OFF the ignition switch.
(3) When the ignition switch is turned ON, ensure that the
charge warning lamp goes on.
(4) After the engine has started, ensure that the charge
warning lamp goes out.
If the warning lamp does not function as specified, trou-
bleshoot the warning lamp circuit.
Immediately flush the affected area using a large amount of clean running water,
until no acid content remains any more.
Immediately flush your eyes using a large amount of clean running water for at
least 15 minutes with your eyes in open state.
Immediately flush the affected area using a large amount of clean running water,
until no acid content remains any more. Afterwards, neutralize them with a soap.
Finally flush them with water.
Immediately flush the affected area using a large amount of water, until no acid
content remains any more. Afterwards, neutralize the area with slacked lime,
sodium or the like.
Immediately flush the mouth with clean water. Let him drink raw eggs. Milk or a
large amount of water. Let him lie quietly.
First-aid treatment
CH–3
JCH00004-00000
JCH00005-00000
JCH00006-00000
JCH00007-00002
Advertisement
Table of Contents
