Daihatsu 1997 Terios J100 Service Manual page 529

DF–6
9. Clean the T type oil seal attaching surface with a piece of
cloth or the like.
10. Thinly apply the lithium soap base multi-propose grease to
the lip section of the T type oil seal.
11. Install a new T type oil seal, using the following SST.
SST: 09635-20010-000
CAUTION:
•
Drive the T type oil seal until the outer surface of the T
type oil seal becomes flush with the flange surface of
the front differential.
12. Install the drive pinion companion flange subassembly, a
new washer plate and a new lock nut.
13. Tighten the new lock nut to the specified tightening torque
while preventing the companion flange from turning, using
the following SST.
SST: 09330-87301-000
Tightening Torque:
14. Stake the lock nut to the recessed part of the drive pinion
shaft, using a suitable chisel or the like properly.
CAUTION:
•
Make sure that the lock section of the nut is positively
staked down to the bottom of the drive pinion groove.
Failure to observe this caution may lead to looseness.
15. Connect the propeller shaft.
(Refer to the PR section)
16. Install and tighten the drain plug with a new gasket inter-
posed.
Tightening Torque:
Front 39.3 - 58.8 N·m (4.0 - 6.0 kgf-m)
Rear 53.9 - 68.6 N·m (5.5 - 7.0 kgf-m)
17. Remove the oil filler plug.
18. Fill the specified differential oil from the oil filler plug hole.
Specified differential oil
Grade :
Viscosity:
:
Capacity:
NOTE:
•
The specified oil level is 0 to 5 mm from the lower end
of the oil filler hole.
19. Install the oil filler plug with a new gasket interposed and
tighten it to the specified tightening torque.
Tightening Torque:
Front 39.3 - 58.8 N·m (4.0 - 6.0 kgf-m)
Rear 53.9 - 68.6 N·m (5.5 - 7.0 kgf-m)
20. Jack down the vehicle.
21. Ensure that no oil leakage exists.
98.1 - 137.2 N·m (10.0 - 14.0 kgf-m)
API GL-5 (Front & rear)
SAE 80W-90 (Standard)
SAE 80W-90 LSD (For LSD)
0.7 liters (Front)
1.55 liters (Rear)
Front
Rear
Filler plug
JDF00011-00010
JDF00012-00011
JDF00013-00012
5 mm
or less
Drain plug
JDF00014-00013