Toyota Celica Supra 1986 Service And Repair Manual page 705

B0-36
J...
-
..
I
I
.t.. _
I .
'
BODY- Sun Roof
ON-VEHICLE INSPECTION
(a) Start the engine and check the operation time of the
sun roof.
Ope<ation t ime: Approx. 5
sees.
(b) Check for abnormal noise or binding during opet•
tion.
(c) With sun roof fully closed, check for water leakage.
ld) Check for a level difference between the sliding panel
and roof panel.
Front s'ode.· o+I.O (0+0.039 · )
-2.0 mm -D.079 on.
Roar
.'
.de·. 0 +1.0 ( 0 +0.039. 1
-2.0 mm -D.079 '"·
Left and right side:
o_:~:8
mm
(oj:8~
in.)
(e) If the sliding roof does not operate:
(1) Remove the cover of the control box.
(2) Remove the screw inside.
(3) Manually operate
the sun roof by inserting a
large screwdriver into the hole and turning the
drive shaft.
ADJUSTMENT OF SLIDING ROOF
(a) Before making adjustments, pull loose the clips and
slide the headlining to the rear.
NOTE: When checking adjustment, reattach the head-
lining before sliding the roof.
(b) Vertical direction of sliding roof front end and rear
end.
Adjust by increasing or decreasing the number of
shims.
NOTE: If the front end is high, even without a shoe
shims, check to see
if
the front shoes are in contact with
the stoppers.
(c) Forward-rearward direction
Adjust by moving the front shoe on both sides.