Fuse And Relay Locations - JLG sky trak mmv Service Manual

Electrical System
10.6.2

Fuse and Relay Locations

a. Fuses & Relays (Left Side Dash)
3
4
6
5
8
7
11
12
14
15
18
19
No. Amp/Volt
1
30 Amp Main
2 15 Amp Ignition - Preheat
3 2 Amp Hourmeter
4 5 Amp Transmission Gear
5 5 Amp Transmission Direction
6 15 Amp Front Dash Display Panel
7 5 Amp Parking Brake
8 7.5 Amp Joystick Logic Panel
9 30 Amp Power Window
10 3 Amp LMI (Load Moment Indicator)
11 2 Amp Service Brake
12 7.5 Amp Front Wiper/Washer
13 7.5 Amp Left Fork Shift
14 5 Amp Steer Mode
15 7.5 Amp Skylight Wiper/Washer
16 7.5 Amp Right Fork Shift
17 7.5 Amp Rear Wiper
18 2 Amp Switch Lamps
19 25 Amp Heater
20 12 Volt Neutral Engage Relay
21 12 Volt Door Window Relay
22 12 Volt Closed Cab Accessory Power Relay
10.12
2 10
1 9
13
20
16
17
Circuit Protected
b. Fuses & Relays (Right Side Dash)
There is a separate fuse holder under the right side of
the dash containing three fuses. This fuse holder is
located in the cab wire harness. To gain access, remove
the three screws that secure the lower dash panel in
place.
To gain access to the fuses remove the cover (23) from
the fuse holder (24).
Refer to the following chart for the size of fuse and circuit
protected.
21
There are seven relays mounted to the front of the cab.
Refer to the following chart for the voltage rating of each
relay and circuit that they control.
22
25
OM10001
23
26
No. Amp/Volt
25
7.5 Amp
26 25 Amp
27 25 Amp
28 24 Volt
29 24 Volt
30 12 Volt
31 12 Volt
32 12 Volt
33 12 Volt
34 12 Volt
33
34
28 29
24
27
Circuit Protected
Fuse - Horn
Fuse - Normal Lights
Fuse - Blackout Lights
Relay - Worklight Power
Relay - High Beam Power
Relay - Brake Light
Relay - Light Power
Relay - Blackout Ignition
Relay - Normal Lights Ignition
Relay - Reverse Signal
Model MMV Rev. 12-04
30
32
31
OM1011