Maintenance Instructions; Maintenance Schedule And Checklist - JLG sky trak mmv Service Manual

General Information, Specifications and Maintenance
2.13

MAINTENANCE INSTRUCTIONS

WARNING:
vehicle without following all safety precautions
as outlined in the "Safety Practices" section of
this manual. Failure to follow the safety prac-
tices may result in death or serious injury.
WARNING:
vice or maintenance on the vehicle with the
engine running. Contact with moving parts can
cause death or serious injury.
IMPORTANT: JLG recommends the use of environmen-
tally sound waste storage and disposal practices.
NEVER drain fluids on the ground or into a sewer or
catch basin. Use suitable collection containers, then
store and/or dispose of waste products in an approved
and safe manner. Check and obey all Federal, State and/
or Local regulations regarding waste storage, disposal
and recycling.
This section contains a routine equipment checklist and a
maintenance schedule and checklist with references to
pertinent procedures and instructions. To help prevent
problems before they occur, follow the maintenance
schedule.
Note: Lubrication (1) and maintenance (2) chart decals
are located inside the engine compartment cover (3).
These decals contain a general maintenance schedule
that should be followed to maintain the vehicle in good
operating condition. The same schedule information is
presented in this manual, except that it contains a more
detailed account of how to perform these specific main-
tenance operations.
2.28
DO NOT service the
DO NOT perform ser-
3
1
2
OS1171
2.13.1

Maintenance Schedule and Checklist

a. 10 Hour Intervals
10
2
H 0
Drain Check
Fuel/Water Engine
Separator Coolant Level
Inspect
Emergency Tire Inflation Tank
Wear Pads
At ten-hour intervals, perform the following:
• Drain the fuel/water separator (refer to Section
2.13.7, Engine Fuel System ).
• Check the engine coolant level (refer to Section
2.13.4, Engine Cooling System ).
• Check the engine oil level (refer to Section
2.13.5, Engine Oil and Filter ).
• Check the hydraulic reservoir oil level (refer to
Section 2.13.9, Hydraulic System Oil and Filter ).
• Check the transmission oil level (refer to Section
2.13.10, Transmission Oil and Filter ).
• Check the air pressure in the tires (refer to Sec-
tion 2.13.15, Wheels and Tires ).
• Check boom wear pad thickness (refer to Section
2.13.19, Boom Wear Pad Maintenance ).
• Drain water from emergency tire inflation tank
(refer to Section 2.13.16, Emergency Tire Infla-
tion System ).
• Inspect and/or clean air compressor intake filter
(refer to Section 2.13.16, Emergency Tire Infla-
tion System ).
Check Check Check Check
Engine Hydraulic Transmission Tire
Oil Level Oil Level Oil Level Pressure
Drain Water From Inspect and/or Clean Air
Compressor Intake Filter
Model MMV Rev. 12/04
MM3211