Advertisement
0-2
LUBRICATION
LUBRICATION AND MAINTENANCE CHART
N O R M A L S E R V I C E
PSF Power Steering Reservoir-Check
level.
If
fluid
i s
cold, level should be at base of filler neck, i f
hot, level should be halfway up flller neck.
Battery-Check
level and specific gravity.
O i l Filter Pipe Breather Cap#- Wash in kerosene
and lubricate with SAE 3 0 engine oil.
below:
Engine Coolant-Check level and/or anti-freeze.
Engine Oil Dlpstlck-When
refueling, check
Corburetor Fuel Filter-Replace
with new filter.
Carburetor Air Cleaner-Paper Element Type-
EO
Clean or replace. Oil Bath Type-Clean
and
refill with SAE 30 Engine Oil.
EO
Engine Oil-Drain
and refill. See viscosity chart
CC
Carburetor Choke Shaft and Linkage-Apply
solvent to choke shaft ends through air horn.
MultiOrades
S
Manifold Heat Control Valve-Treat
shaft with
SAE 2OW-40 Where temperatures are consistently
solvent.
above 32' F .
Crankcase Ventilatlon System-Test system and
SAE 1OW-30 Suitable for year long operation in many
service, as required.
parts of the US.; may be used where
Engine Oil Filter-Replace with new fllter.
temperatures occasionally drop as low
A A
Automatic
Transmission-Check
level
with
engine idling in neutral and thoroughly warm.
as -1OOF.
DCL Distributor Cam and Rubbing Block-Apply
to
Recommended where minimum tempera-
cam and rubbing block.
tures consistently are below +1 O' F .
Single Grades
EO
Distributor Oil Cup and Cam Wlck under
SAE 5W-20
SAE 3 0
Where temperatures consistently are
Rotor block.
SAE 1OW
Where temperatures range
between
G Front Brake Assemblies and Wheel Bearlngs
Body Mechanism-See
Body Maintenance
HL
Manual Steering Gear-Check
level. Add lubri-
Section
or
cant, if necessary.
MP
MML
Column-Mounted Manual Transmission Gear-
shift Controls-Apply
film of lubricant to con-
tact surfaces.
above 32' F .
Engine Tune-up
+32OF. and -1 0°F.
MML
Column-Mounted Automatic Transmlsslenl
/ /I
2
or
Controls-If
boot
i s
damaged, replace and
AMG relubricate mechanism.
necessary.
damage. Replace if necessary.
MML
Front Suspension Ball Joints-Inspect
seals for
HTF Brake Master Cylinder-Check
level.
Fill if
I / /
l ,
T /
$ '
f
7
MML
Steering Linkage Boll Joints-Inspect
seals for
MML
or
Clutch Torque Shaft.
AMO
MML Clutch Drive Lugs, Release Bearing Sleeve,
or
Fork Fingers and Pivot.
AMG
EO
Floor Mounted Manual Transmission Gear-
shMt Mechanism-Lubricate
mechanism from
under car with light with SAE 30
Floor Mounted Automatic Transmission Con-
holr-Lubricate
with SAE
30
after removing
console toD trim aanel.
damage, replace
if
damaged or worn.
EO
A A
Manual Transmlrsion-Check
level, maintain to
filler hole.
UJ
HL
or
Universal Joints-Inspect
seals for leokage.
/
Inspect joints parts for wear.
Rear Axle and SureQrip-Check
level. Main-
tain level to flller hole.
I \
ll
/
Position for lift adapter
M I
#See Crankcase Ventilation System Servicing.
I
A
Prepacked bearing
0
Cooling system drain
TIRE PRESSURES (PSI) (COLD)
Size
Front Rear
1
7.00~13 AV-2 exceDt Sta. woo.
24
22
1
7.00~13 AV-2 Station Wagon
-
7.00~13 AV-2 Barracuda
7.75~14 AR-2 Station Wagon
7.75~14 ARO-2 except Station
7.35~14 AR-2
Wagon
7 7 5 x 1 4 AP-2
8.25~14 AP-2 with
"B"
engine
8.55~14 AP-2 and/or air condition-
ing Stotion Wagons
22
24%
24
24
24
22
24
26%
24
22
24
22
24
22
22
26*
*Increase rear tire pressure
6
psi on loaded
Station Waaons.
PLYMOUTH
I
V=8
NK574
Fig. 2-lubrication
System
(V-8 Models)
Deck Lid Hinges
Door Hinges
Door Striker Plates
Door Striker Rotor
Fuel Tank Filler Door
Hood Hinges
Tailaate Torsion Bar and Check Arm Guide Plate
Throile Linkage
KEY TO LUBRICANTS
A A
Automatic Transmission
AMG Automotive Multi-Purpose Ormse
CC
Carburetor Cleaner
DCL Corn Lubricant
1473595
EO
Engine Oil
HTF High Temperoture Brake Fluid 2421352
HL
Hypold Lubricant
1879414
ML
Lubtipiate
1064768
MML Multi-Mileage lubricant
2525035
MP
Multi-Purpose Gear Lubricant
PSF
Power Steering Fluid
2084329
S
Manifold Heat Control Valve
Solvent
18793 18
SL
Stoiniess Stick Lubrlcant
1064769
UJ
Universal Joint Grease
Fluid, AQ-ATF, Suffix "A"
1843314
CAPACITIES
Engine Oil.
..............................
. 4 qts.
Cooling AV-2 Models..
..................
.17 qtr.
system AR-2 AP-2 Models..
.............
.2O qts
Reor Axle AV-2 Models.
....................
.2 pt%
AR-2 AP-2 Models.
...............
.4 ph.
AV-2 Models..
................
.I7
pth
AR-2, AP-2
model^.
..........
.19.5 pts.
AV-2, AR-2, AP-2 Models.
....
.4.5 ptS
AV-2 Models..
...............
.7
pts
AR-2, AP-2 Models.
.........
.7.5 pts
Fuel Tank AV-2 Models..
.................
.18
gals,
Wagons..
..................
.19 gob,
AR-2 Stotion Wagons..
..........
.21
gals,
(Add 1 qt. when replacing fllter)
AR-2 (361,383 and 426 cu.in. engines)l 6 qts.
(Add
1
qt. for heater)
Transmission
TorqueFlite
Manual 3-Speed
4 -Speed
AR-2 Models except Station
AP-2 Models
except Station Wogons.
.......
.25 gals.
AP-2 Station Wagons.
. . . . . . . . . . .
.22 gath
Hide quick links:
Advertisement
