Advertisement
GROUP 0
LUBRICATION A N D M A I N T E N A N C E CHART
N O R M A L S E R V I C E
Engine Coolant-Check
level and /or anti-freeze.
Battery-Check
level and specific gravity.
i s
cold, level should be at base of filler neck,
hot, level should be halfway up filler neck.
Carburetor Fuel Filter-Replace
with new filter.
Engine Oil Dipstick-When
refueling, check
engine oil level.
Carburetor Choke Shaft and Linkage-Apply
solvent to choke shaft ends through air horn.
solvent.
Carburetor Air Cleaner-Paper
Element Type-
Clean or replace. Oil Bath Type-Clean
and
E
3 0
Where temperatures consistently are
refill with SAE 30 Engine Oil.
HL
Manual Steering Gear-Check
level. Add Iubri-
E
1OW
Where temperatures range between
or
cant, if necessary.
+32' F .
and -1 O°F.
MP
L Distributor Cam and Rubbing Block-Apply
to
MML Column-Mounted Manual Transmission Gear-
shift Controls-Apply
film of lubricant to con-
Distributor Oil Cup and Cam Wick undor
tact surfaces.
Rotor block.
EO
Oil Filter Pipe Breather Cap#-Wash in kerosene
and lubricate with SAE 3 0 engine oil.
PSF Power Steering Resorvoir-Check
level. If fiui
EO
Engine Oil-Drain
and refill. See viscosity chart
below:
Multl-Orados
SAE
2OW-40
Where temperatures are consistently
above 32' F .
SAE
1OW-30
Suitable for year long operation in many
parts of the
US.;
may be used where
CC
temperatures occasionally drop as low
as
-
1 O°F.
S
Manifold Heat Control Valvo-Treat
shaft with
SAE
5W-20
Recommended where minimum tempera-
tures consistently are below +1 O°F.
Single Grades
above 32'F.
cam and rubbing block.
MML Column-Mounted Automatic Transmission
or
Controls-If
boot
i s
damaged, replace and
Crankcase Ventilation System-Test system and
AMG relubricate mechanism.
HTF Brake Master Cylinder-Check
level.
Fill if
A A
Automatic
Tronrmission-Check
level
with
necessary.
engine idling in neutral and thoroughly warm.
Engine Tune-Up
MML Front Surponsion Ball Joints-Inspect
seals for
damage. Replace if necessary.
G Front Brake Assemblies and Wheel Bearings
MML Steering Linkage Ball Joints-Inspect
seals for
Universal Joints-Inspect
seals for leakage.
damage, replace if damaged or worn.
Inspect joints parh for wear.
MML
Roar Axle and Sure-Grip-Check
level. Main-
tain level to filler hole.
or
Clutch Torque Shaft.
AMG
MML Clutch Drive Lugs, Release Bearing Sleeve,
or
Fork Fingers and Pivot.
AMG
EO
Floor Mounted Manual Transmission Gear-
shaft Mochanlsm-Lubricate
mechanism from
under car with SAE 3 0
Floor Mounted Automatic Transmission Con-
trols-lubricate
with SAE 30 after removing
console top trim panel.
A A
Manual Transmission-Check
level, maintain
to filler hole.
Body Mechamlsm-See
Body Maintenance
Group
Deck Lid Hinges
Door Hinges
Engine O i l Filter-Replace with new filter.
service, as required.
MP
#See Crankcase Ventilation System Servicing.
EO
n Bar and Check Arm Guide Plate
A A
Automatic Transmission
AMG Automotive Multi-Purpose Ormso
CC
Carburotor Cleaner
DCL Cam Lubricant
1473595
EO
Engine Oil
HTF
High Temperature Brake Fluid
2 4 2 1 3 5 2
HL
Hypoid Lubricant
1879414
ML
Lubrlplate
1064768
MML Multi-Mileage Lubricant
2525035
MP
Multi-Purpose Gear Lubricant
PSF
Power Steering Fluid
2 0 8 4 3 2 9
Fluid, AO-ATF, Suffix "A"
1843314
Position for lift adapter
A
Prepacked bearing
0
Cooling system drain
PLYMOUTH 6
Manifold Heat Control Valve
NK571
Solvent
187931 8
Stolnlesr Stick Lubricant
1064769
Fig. 1 --Lubrication Chart
UJ
Universal Joint Grease
(6-Cyl. Models)
TIRE PRESSURES (PSI) (COLD)
Size
Front
650x13 AV-1
24
650x1 3 AV-1 Barracuda
24
7.00~13 AV-1 with A.C.
24
7.00~13 AV-1 Station Wagon
with A.C.
24
7.35~14 AR-1 except Station
7.75~14 AR-1 Station Wagon
22
7.35~14 AP-1
24
7.75~14 AP-1 with A.C.
24
8.25~14 AP-1 Station Wagons-
*increase rear tire pressure 6 psi
on
IC
Wagon
22
4 PlY
22
station wagons.
Rear
24
26
22
24*
22
26*
24
22
26*
laded
CAPACITIES
Engine Oil.
........................
.4 qts.
AV-1 Models..
...................
.11 qts.
AR-1, AP-1 Models..
.............
.12 qts.
AV-1 Models..
...................
.2 pts.
AR-1, AP-1 Models.
...............
. 4 pts.
TorqueFlite.
.....................
.17 qts.
3-Speed.
......................
.6 pts.
4-Speed.
......................
.7
pts.
(Add 1 qt. when replacing filter)
Cooling System
(Add 1 qt. for heater)
Rear Axle
Transmission
Manual
Fuel Tank
AV-1 Models..
.................
.18 gals.
AR-1 Models..
................
.19 gals.*
AP-1 Models..
...............
.25 gals.**
*Station Wagons..
...............
.21 gals.
**Station Wagons..
...............
.22 gals.
Hide quick links:
Advertisement
