Honda CB 600F Hornet 2007 Shop Manual page 93

MAINTENANCE
Major adjustment is performed at the clutch lifter
lever.
Loosen the lock nut and turn the adjusting nut to
adjust the freeplay.
Tighten the lock nut while holding the adjusting nut.
If proper freeplay cannot be obtained, or the clutch
slips during test ride, disassemble and inspect the
clutch (page 9-6).
SI DEST AND
Support the motorcycle on a level surface.
Check the sidestand spring for damage or loss of
tension.
Check the sidestand for smooth movement and
lubricate the sidestand pivot if necessary.
Check the sidestand ignition cut-off system:
- Sit astride the motorcycle and raise the side­
stand.
Start the engine with the transmission in neutral,
then shift the transmission into gear, with the
clutch lever squeezed.
Move the sidestand full down.
The engine should stop as the sidestand is low­
ered.
If there is a problem with the system, check the side­
stand switch (page 20-23).
SUSPENSION
FRONT SUSPENSION INSPECTION
Check the action of the forks by operating the front
brakes and compressing the front suspension sev­
eral times.
Check the front suspension assembly for signs of
leaks, damage or loose fasteners.
Replace damaged components which cannot be
Loose, worn or
repaired.
damaged
Suspension perts
Tighten all nuts and bolts.
,mpe,r mo1orcycles
Refer to the fork service (page 13-21 ).
stab//,ty and
contJo/.
3-28
� ... �., ..
SI DEST AND