Honda CB 600F Hornet 2007 Shop Manual page 500

TROUBLESHOOTING
BATTERY IS DAMAGED OR WEAK
1. BATTERY TEST
Remove the battery {page 17-6).
Check the battery condition using the recommended battery tester.
RECOMMENDED BATTERY TESTER:
BM-210 or BATTERY MATE or equivalent
Is the battery in good condition?
YES
NO
2. CURRENT LEAKAGE TEST
Install the battery {page 17-6).
Check the battery current leakage test !Leak test; page 17-7).
Is the current leakage below 2. 0 mA 7
YES
NO
3. CURRENT LEAKAGE TEST WITHOUT REGULATOR/RECTIFIER CONNECTOR
Disconnect the regulator/rectifier connector and recheck the battery current leakage.
Is the current leakage below 2.0 mA7
YES
NO
4. AL TERNA TOR CHARGING COIL INSPECTION
Check the alternator charging coil (page 17·8).
Is the alternator charging coil resistance within 0. 1
YES
NO
5. CHARGING VOLTAGE INSPECTION
Measure and record the battery voltage using a digital multimeter (page 17-6).
Start the engine.
Measure the charging voltage (page 17-7).
Compare the measurement to result of the following calculation.
STANDARD: Measured BV < Measured CV< 15.5 V
Is the measured charging voltage within the standard voltage?
YES
NO
6. REGULATOR/RECTIFIER SYSTEM INSPECTION
Check the voltage and resistance at the regulator/rectifier connector (page 17•8).
Are the results of checked voltage and resistance correct?
YES
NO
- GO TO STEP 2.
- Faulty battery
- GO TO STEP 4.
- GO TO STEP 3.
- Faulty regulator/rectifier
- • Shorted wire harness
• Faulty ignition switch
- GO TO STEP 5.
- Faulty charging coil
• BV = Battery Voltage {page 17-6)
• CV= Charging Voltage
- Faulty battery
- GO TO STEP 6.
- Faulty regulator/rectifier
- • Open circuit in related wire
• Loose or poor contacts of related terminal
• Shorted wire harness
BATTERY/CHARGING SYSTEM
a
-
1.0 (20"C/68 ° F)7
17-5