Winnebago 1987-1989 LeSharo Service Manual page 636

COMPONENTS
The major componentns of the system are:
)
)
Split Plastic
Retainer Snaps
Into Groove
Not Included in Kit
~
"'0" Ring
-t :"
'Transmission Seal ~ ~~----
Cable \
/")1Y'
TRANS.
'Signal 'Seal ,
-')Vl
Generator \ ~).
Speedometer \ ,>::;;t/y"speedometer
Cable-Lower ~ Cable-Upper
\ A!~\\
~~~0~~",
~7
'>-"
//
',',
,I
~ ..•..
/)
~---".....-/ 'These Parts Furnished Assembled
'""Wire Tie
AUXILIARY TRANSMISSION KICK-DOWN SWITCH
CAUTION
SIGNAL GENERATOR
All other parts in the kit are for connecti ng these
components to the vehicle, and to each other.
• Signal Generator • attached to the speedometer
cable drive adaptor at the transmission.
• Regulator. a computer board mounted behind the
instrument panel.
• Servo· mounted in the engine compartment and
linked to the throttle.
• Control Switch· on the steering column near the
turn signal lever.
• Disengagement Switch/Dump Valve Assembly •
operated by the brake pedal.
Be SURE all square driving members and
speedometer cable are properly engaged with their
mating counterparts and all cable nuts are tight.
"Snap-in" type ends must be completely engaged.
Explanation of Auxiliary Switch: When the Cruise
Control is pulling on the throttle, the vehicle's
existing trans. kick-down switch cannot be activated
because the vehicle's throttle cable is at rest. The
switch is activated when cruise cable moves to nearly
full end of its travel. The throttle linkage strikes
switch lever and closes the contacts of switch to
activate kick-down.
A. Bracket and Micro-Switch Assembly. To install
unscrew metric hex head. screw, slip notch of
bracket under lock-washer and retighten screw
to hold switch bracket.
(See
Figure 7).
NOTE: Switch is factory adjusted, but if kick-down
need be adjusted, the lever of the switch can
be bent to get adjustment. After adjusting,
move throttle by hand to full open to see
that switch IS NOT acti ng as a stop.
Vehicle Firewall ~ -~' _
Kick-Down ~ ,// , ~-
--0.- ,~ SWItch /'.
\ (,', ).~/ , , ,E,
x,sting
j~'!\''1' / \
Harness
~~flJ/ /~-,\-,.,
< ..,;/
"~y.~ ------ "
,
\
~
~:~:,---
/
r,\
&,"
598-02494
Existing ,
J'
Harness
Throttle ,- Assembly
Cable ~, ,
Assembly Auxiliary
,~~I,
~~,)<>
Kick-Down
-r, -' ..•. ~,
SWItch
l.t:;1Ov ~
/-y'
.::f'"
Figure 7
02-2