Subaru 1600 Service Manual page 661

BODY
14·9. Sunroof (Option)
1. Sedan and Hardtop
@ CD
View "A"
View"B"
View"C"
Fig. 14·203
Removal of Glass
1) Move handle down and then up,
and tilt (pop) up glass.
2) Remove handle from base plate.
Fig. 14·204
A24·803
3) Slide safety catcher knob to reo
lease safety lock. ",-"
~ "'~~~~.
~
Fig. 14·205
A24-733
4) Remove male hinge from female
hinge while lifting glass.
The glass should be detached along the
arc shape of male hinge.
5) Place glass into a suitable bag and
store in trunk room.
6) When installing glass, press on de-
flector with glass.
Observe the following precautions
during installation:
a. Ensure that weatherstrip is installed
properly. If it is rolled in or caught
by the car body, raise weatherstrip.
b. Be careful not to strike male hinge
against the car body.
c. Ensure that safety lock and handle
lock operate properly.
Repair of Drain Tubes
1) Front drain tube
a. Remove roof trim and side rail
trims.
b. Remove drain tube on the side of
the roof, then pull it out of the
roof.
c. Insert a (new) tube into the pillar
from the side of the roof, then
secure it to the roof.
14-66
1 Glass ASSY
2
Handle
3 Safety catcher
4 Male hinge
5 Weatherstrip
6 Drain tube
7 Base plate
8 Safety striker
9 Deflector
10 Female hinge
A24·802
d. Remove lower pillar trim, then
insert tube into the hole of separa·
tor.
I )
III
\
'
\
- -~~~ ,~~:
o ..
'<
~~~
Fig. 14-206
A24·734
e. Install all trims in their original
positions.
2) Rear drain tube
a. Remove roof trim.
b. Remove drain tube on the roof,
then pull
it
out of the roof.
c. Insert a (new) tube into place from
the roof side.
d. Remove trims from around rear
quarter window to ensure that the
tube can be seen.
• , __ "., ........... 4» ....... _. - , -.... - - , - ' - , , _ , ,,",'
r ... ·_·
.-.~
_w _ _ _ _ '''"'''_,_--_ _ _ - - - - - - - - - - - - -