Subaru 1600 Service Manual page 262

MANUAL TRANSMISSION AND DI FFERENTIAL
NOTE:
•• Stop scrawlng wh.n tha thrlld il
antlr.ly amb.ddad bafora the
hold.r rllches the specified POIi-
tion.
~~\\7i\.
-
t~~ '';~'c.~'-~ '-
~,
\ '---.J
I
\~
...... I
,0
,Wrench (399780111)-
I'
\"J~~.~
~---.~
Fig. 6-726
b. M.ke lure to Instill the holder with
'L'
marked oU .. al.
3) After installin. outer snap ring
and washer onto speedometer shaft, fit
them into case. Install speedometer
driven gear on shaft and retain with
snap ring.
Sh,ft
Fig. 6·727
NOTE:
_ Outer In,p ring
'WI.h.r
[12.15
Ie
115.15
Ie
10
mm
10.482
Ie
0.810
Ie
0.39 Inll
A12-071
When instilling tha outer snap ring
(806012020) onto the Ipeedometer
drivi shaft. inllrt it
from thl driven
gaer lide.1 shown in th •• bove figura.
4) Drive in 011 seal with Press
(499827000).
.. 12·080
Fig. 6- 728
S) !4WD Dual-range
I
Install oil seal in transmission main
case (L.H.).
Fig. 6·729
A12·412
6)
I
Other than S·speed
1
Install reverse shifter rail arm to the
end of reverse shifter lever. Fit reverse
shifter rail and tiahten shifter fork set
screw.
Torque
Fig.
(J.
730
7)
I
S-speed
I
18.1 - 21.1 N·m
(1.8S - 2.1 S kg·m,
13.4 - lS.6 ft·lb)
,,'2·082
Put reverse shifter
arm
spring and ball
in reverse shlfter rail arm.
Install reverse shifter ralltnto case and
arm
with Installer (399411700) and
then fit snap ring (outer).
1 Arm (reverie shifter rail)
2 In.taller (399411700)
Fig. 6·737
6-45
A12·141
8) Install reverse idler gear and
reverse idler gear shaft and retain with
knock pin.
1
2
= 0
9) [4WD Dual·range
I
A12·483
Install the following parts onto
counter gear shaft.
1 O·ring
2 Knock pin (at front side)
Fig. 6·733
..12·3e2
1
Q·rlna
(21.5 )( 1.5)
2 Knock pin (4 )( 6)
10) !4WD Dual·range
I
Install the following parts onto
counter gear shaft as installing shaft
into main case (R.H.), and push
it
perfectly into case.
1 Two counter gear washers
2 Two needle bearings
3 Counter gear collar
4 Counter gear
S Knock pin
6 Clip
NOTE:
Make lura that cut-out and lurfaca of
counter ge.r sh.ft dOli not protruda
.bove tha and lurface of tha c .. e.
Fig.
6·134