Subaru 1600 Service Manual page 10

GENERAL INFORMATION
P:1-6.
Recommended Sealants, Adhesives and Greases
f
-----=---
Recommended
Application Equivalent
Fuji Bond C
Mating surfaces of crank and transmission
Dow Coming's
(pIN 004403004) cases, plugs, etc. No. 7038
Fuji Bond D Cover gasket of water pump (Fuji Bond C
(PIN 004403005) can be used instead), etc.
1. Sealant
Three Bond 1215
Flywheel bolts, mating surface of fly· Dow Corning's
(PIN 004403007)
wheel housing. No. 7038
Three Bond 120 I Cylinder head gaskets (Super Three Bond Dow Coming's
(PIN 004403008)
50 can be used for the same purpose).
No. 3145
Starcalking B·33A
Sealing against water and dust entry Butyl Rubber
(pIN 000018901) through weatherstrips, grommets, etc. Sealant
Cemedine 5430L
Weatherstrips and other rubber parts,
3M's
plastics and textiles except soft vinyl EC·I770
-
parts. EC·1368
Soft vinyl parts, and other parts subject
3M's
EC·776
Cemedine 540 to gasoline, grease or oil.
EC·847
-
e.g. trim leather, gear shift boot, door
EC·1022 (Spray
2. Adhesive
inner remote cover, etc.
Type)
Cemedine 3000
Bonding metals, glass, plastic and rubber Armstrong's
parts. Repairing slightly tom weather- Eastman
-
strips, etc.
910
Starseal U-70 for Weatherstrips securing windshield to body
Essex Chemical
USA & Canada
panels to meet the requirements of Motor
Corp's
-
Vehicle Safety Standard.
Urethane E
FX clutch grease
Splines of transmission main shaft.
(P
IN
000040901)
Molylex No.2
CVJ and DOJ joints of axle shafts.
(PIN 623029980)
PBC Stopper plugs of the front disk brake
(pIN 003607000) caliper.
Silicone KS64
Brake caliper body (piston, spindle
(pIN 003606010)
adjuster O·ring), battery terminals,
3. Grease
distributor, hood latch, etc.
Control cables and carburetor linkages
Silicolube G·30M subject to cold weather, water·pump
(P
IN
004404002)
impeller, door latch, striker, battery
terminals, etc.
ABK 100 Contacting surfaces of drum brake shoes
(pIN 003602000) and shoe clearance adjuster.
Niglube RX·2
Disk brake caliper (lever, connecting link
(pIN 003606000) and spindle head).
Valiant grease M·2
~teering
gearbox (Both manual and power
(pIN 003608001) teering)
NOTE: The adhesives in the above table are not avail ble from our parts department. Some of them and their equivalent
products may be purchased from your local ven, ors.