Audi Q7 2007 Repair Manual page 297

⇒ "16.9 Drive Plate Run-Out with Overload Protection, Checking and Adjusting (Vehicles with 8-Cylinder
FSI Engine)", page 294
❑ Removing and installing. Refer to
⇒ "16.8 Drive Plate with Overload Protection, Removing and Installing (Vehicles with 8-Cylinder FSI
Engine)", page 293
4 - Drive Plate
❑ Attached to compressor input shaft
❑ With overload safeguard, triggers when torque is too-high (for example, compressor produces friction)
and driveshaft runs freely without driving the compressor.
❑ Tightening specification 30 Nm
❑ Removing and installing. Refer to
⇒ "16.10 Drive Plate, Removing from A/C Compressor and Installing (Vehicles with 8-Cylinder FSI En‐
gine)", page 294
5 - Rubber Element
❑ Decouples drive unit, dampens vibrations and noises.
❑ When installing, coat rubber element lightly for example, using soapy water (as sliding compound).
❑ Removing and installing. Refer to
⇒ "16.10 Drive Plate, Removing from A/C Compressor and Installing (Vehicles with 8-Cylinder FSI En‐
gine)", page 294
6 - Spacer
❑ The original disc must be installed.
❑ Dimensions: 17.5 x 10 x 3 mm
7 - Circlip
❑ Replace
❑ Install on proper side (level side to compressor)
❑ Removing and Installing. Refer to
⇒ "16.11 Drive Plate with Cylindrical Roller Bearing, Removing and Installing (Vehicles with 8-Cylinder
FSI Engine)", page 295
8 - Drive Plate
❑ With roller bearing.
❑ Removing and installing. Refer to
⇒ "16.11 Drive Plate with Cylindrical Roller Bearing, Removing and Installing (Vehicles with 8-Cylinder
FSI Engine)", page 295
❑ Clean compressor flange before sliding on drive plate.
9 - Compressor
❑ Different versions may be installed, depending on engine version and country version of vehicle. Refer
to the Parts Catalog.
16. Compressor, Removing and Installing (Vehicles with 8-Cylinder Engine and 12-Cylinder TDI Engine)
Heating, Ventilation and Air Conditioning - Edition 04.2013
.
.
.
.
.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
.
Audi Q7 2007 ➤
291