Audi Q7 2007 Repair Manual page 125

– Insert the studs on the Defroster Door Motor - V107- -A- lever
into guiding groove of lever on defroster door -D-.
Note
Item -H- shows the respective adjustment range of the control
motors.
Remove the control motor on retaining plate.
– Install the removed components again in reverse order.
– Check the DTC memory of the Climatronic Control Module -
J255- front A/C control head and erase DTCs displayed if
necessary. Use the Vehicle Diagnostic Tester via the "Guided
Fault Finding" function.
– Perform basic setting (and final control diagnosis, if necessa‐
ry) on the A/C system. Use the Vehicle Diagnostic Tester via
the "Guided Fault Finding" function.
9.12.2 Defroster Door Motor - V107- , Remov‐
ing and Installing, Instrument Panel In‐
stalled
Note
The Defroster Door Motor Position Sensor - G135- is installed
♦
in the Defroster Door Motor - V107- .
This motor is fastened on the right on the A/C unit in vehicles
♦
with right-side steering. Refer to
⇒ "9.27 Retaining Plate with Control Motors V111 and V300 ,
Removing and Installing", page 158
The control motor is secured to a retaining plate, this retaining
♦
plate can then only be removed and installed with the instru‐
ment panel installed when bolts -C- are not tightened too
tightly. Refer to
⇒ "9.15 Retaining plate with Defroster Door Motor V107 , Left
Side Vent Motor V299 (and Left Center Vent Motor V110 ),
Removing and Installing", page 128
the connection of the lever on the control motors to the levers
on the doors cannot be checked with the instrument panel in‐
stalled, it makes sense to remove the instrument panel and
remove and install the control motor with the retaining plate
installed, despite the great amount of work involved to remove
and install this control motor.
Removing
Heating, Ventilation and Air Conditioning - Edition 04.2013
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
.
. Since on the other hand
9. A/C System Control Components Inside Passenger Compartment
Audi Q7 2007 ➤
119