Ford Transit 2002 Owner's Manual page 854

*
Engine starts but *
immediately stops
and glow plug
indicator is flashing
Engine starts but *
immediately stops
*
*
*
*
Poor idling and glow *
plug indicator is
flashing
Poor idling *
*
*
*
*
*
*
Engine stumbling *
and glow plug
indicator is flashing
Engine stumbling *
*
*
*
Engine lacks power *
and glow plug
indicator is flashing
Engine lacks power *
*
*
Low cylinder *
compression.
DTC detected. *
Air ingress into the *
fuel lines.
Blocked or damaged *
fuel filter.
Sensor(s). *
Fuel injection pump
control unit.
PCM.
DTC detected. *
Fuel filter blocked. *
Contaminated fuel.
Air ingress into the
fuel lines.
Sensor(s). *
Fuel injection pump. *
Fuel injector(s). *
Fuel injection pump *
timing.
DTC detected. *
Air ingress into the *
fuel lines.
Sensor(s). *
Fuel injection pump. *
Fuel injector(s). *
DTC detected. *
Brakes binding. *
Vehicle overloaded, *
or excessive wind
resistance (roof
racks, towing etc).
Charge air cooler *
blocked or cracked.
http://vnx.su
of injectors as required only after the specialist
agent checks have been carried out.
REFER to Section 303-00 Engine System -
General Information.
REFER to WDS.
REFER to Section 310-00A Fuel System -
General Information / 310-00B Fuel System -
General Information.
INSTALL a new fuel filter.
REFER to WDS.
REFER to WDS.
REFER to Section 310-00A Fuel System -
General Information / 310-00B Fuel System -
General Information.
REFER to WDS.
REFER to WDS.
Have the fuel injectors checked by an
appropriate fuel injection specialist agent.
CLEAN the fuel injectors or INSTALL a new set
of injectors as required only after the specialist
agent checks have been carried out.
CHECK the fuel injection pump timing.
REFER to Fuel Injection Pump - 1.8L Diesel
(75PS) in this section.
REFER to WDS.
REFER to Section 310-00A Fuel System -
General Information / 310-00B Fuel System -
General Information.
REFER to WDS.
REFER to WDS.
Have the fuel injectors checked by an
appropriate fuel injection specialist agent.
CLEAN the fuel injectors or INSTALL a new set
of injectors as required only after the specialist
agent checks have been carried out.
REFER to WDS.
CHECK the braking system. REFER to Section
206-00 Brake System - General
ADVISE the customer about the effects of
overloading the vehicle and wind resistance on
the fuel consumption.
INSPECT for visible signs of damage or
blockage. CLEAN, REPAIR or INSTALL new parts
Information.