Ford Transit 2002 Owner's Manual page 901

Visual Inspection Chart
Fuel leak(s)
Fuel filter
Air cleaner element
Vacuum line(s)/vacuum connections
Hose(s)/hose connections
Tube(s)/tube connections
Contaminated fuel
Fuel supply line(s)
Fuel return line(s)
High-pressure fuel supply line(s)
Fuel injectors
Fuel rail
Fuel pump
3. 3. If an obvious cause for an observed or reported concern is found, correct the cause
(if possible) before proceeding to the next step.
4. 4. If the cause is not visually evident, verify the symptom and refer to WDS to
retrieve the diagnostic trouble codes (DTCs).
5. 5. If no DTCs related to the concern are retrieved, proceed to the Symptom Chart
below to continue diagnostics.
Symptom Chart
Symptom Possible Sources
Engine does not * PATS system fault
crank and passive detected.
anti-theft system
(PATS) LED is
flashing
Engine does not * DTC detected.
crank and glow
plug indicator is
flashing
Engine does not * Starting system.
crank
Engine cranks but * DTC detected.
does not start
and glow plug
indicator is
flashing
Engine cranks but * Low fuel tank fuel
does not start level.
* Fuel filter blocked.
* Fuel lines damaged
or blocked.
Mechanical
* REFER to:
- Passive, Diagnosis and Testing).
* REFER to the WDS.
* REFER to:
08/2006
Testing).
* REFER to the WDS.
* CHECK the fuel tank fuel level is greater than four
liters. If the fuel tank fuel level is less then four
liters, FILL with fuel.
* INSTALL a new fuel filter.
REFER to:
Diesel
Installation).
* REFER to:
(Lynx) Diesel (75 PS/90 PS/110 PS), Vehicles Built
From: 08/2006
Information, Diagnosis and Testing).
http://vnx.su
Electrical
Fuse(s)
Relay(s)
Wiring harness
Electrical connector(s)
Sensor(s)
Action
Anti-Theft - Passive
Starting System - Vehicles Built From:
(303-06 Starting System, Diagnosis and
Fuel Filter - 1.8L Duratorq-TDCi (Lynx)
(310- 01A Fuel Tank and Lines, Removal and
Fuel System - 1.8L Duratorq-TDCi
(310-00A Fuel System - General
(419-01B Anti- Theft