Ford Transit 2002 Owner's Manual page 909

* Catalytic converter
blocked.
* CHT sensor.
* MAF sensor.
* MAP sensor.
* Fuel injector(s).
* FRP sensor.
* Intake manifold
EGR throttle.
* Intake manifold
EGR throttle
vacuum control
solenoid.
Blue smoke and * DTC detected.
glow plug
indicator is
flashing
Blue smoke * Engine burning oil.
* Incorrect or
contaminated fuel.
From: 08/2006, Vehicles With: Variable Vane
Turbocharger (303- 04C Fuel Charging and Controls
- Turbocharger, Diagnosis and Testing).
* REMOVE and visually INSPECT the catalytic
converter for damage. INSTALL a new catalytic
converter as necessary.
* REFER to the WDS.
* REFER to the WDS.
* REFER to the WDS.
* REFER to the WDS.
* REFER to the WDS.
* CHECK the intake manifold EGR throttle butterfly
for obstructions and correct operation.
* REFER to the WDS.
* CHECK the intake manifold EGR throttle vacuum
control solenoid vacuum lines for kinks or
restrictions.
* REFER to the WDS.
* REFER to the WDS.
* CARRY OUT a controlled oil consumption test over
1000 km (600 miles). CONFIRM that the oil
consumption is less than 0.1 of a litre per 1000 km
(600 miles).
REFER to: Engine (303-01B Engine - 1.8L
Duratorq-TDCi (Lynx) Diesel/1.8L Duratorq-TDDi
(Lynx) Diesel, Diagnosis and Testing).
* CHECK for signs of contamination such as strange
odors from the fuel tank.
* CHECK for signs of water or petrol in the diesel.
* If contaminated fuel is found, DRAIN the complete
fuel system. FLUSH the fuel system through with
clean diesel.
REFER to: Fuel Tank Draining
System - General Information, General
Procedures).
INSTALL a new fuel filter element.
REFER to: Fuel Filter - 1.8L Duratorq-TDCi (Lynx)
Diesel (310- 01A Fuel Tank and Lines, Removal and
Installation).
INSTALL a new fuel pump, fuel injectors, fuel rail,
and high-pressure fuel supply lines.
REFER to: Fuel Injection Pump - 1.8L Duratorq-
TDCi FGT (55kW/75PS) - Lynx/1.8L Duratorq-TDCi
(66kW/90PS) - Lynx/1.8L Duratorq-TDCi FGT
(66kW/90PS) - Lynx/1.8L Duratorq-TDCi VNT
(66kW/90PS) - Lynx/1.8L Duratorq-TDCi VNT
(55kW/75PS) - Lynx/1.8L Duratorq-TDCi
(81kW/110PS) - Lynx, Vehicles Built Up To:
03/2008 (303-04B Fuel Charging and Controls -
1.8L Duratorq-TDCi (Lynx) Diesel/1.8L Duratorq-
TDDi (Lynx) Diesel, Removal and Installation) /
Fuel Injection Supply Manifold - 1.8L Duratorq-
TDCi (Lynx) Diesel
Controls - 1.8L Duratorq-TDCi (Lynx) Diesel/1.8L
Duratorq-TDDi (Lynx) Diesel, Removal and
Installation) /
http://vnx.su
(310-00A Fuel
(303-04B Fuel Charging and