Honda CR-V 1997 Service Manual page 670

Symptom-to-Component Chart
Hydraulic System (cont'd)
SYMPTOM
Check these items on the Check these items on
PROBABLE CAUSE List the NOTES List
Shift lever does not operate smoothly.
6, 38 P
Fails to shift; stuck in 4th gear.
18, 47 , 48
Transmission will not shift into park in
[fJ
position. 6,38, 61 P
Stall rpm high; all clutch pressures are in specification. 40
D,K,O
lock-up clutch does not disengage.
18, 43, 44,45, 46, 49, 50, 57 E,L
Lock-up clutch does not operate smoothly. 18,40, 43,44,45, 46,49, 50,57 L
Lock-up clutch does not engage.
18,40, 43, 44, 45,46, 49,50, 56, 57 E, L
Vibration in all positions. 35
No engine braking in
m
position. 59
Shift position indicator does not indicate any position.
6, 38, 60
PROBABLE CAUSE
1 LowATF 33 Thrust washer worn/damaged
2
ATF pump worn or binding
34
Clutch clearance incorrect
3
Regulator valve stuck or regulator valve
35
Drive plate defective or transmission misas-
spring worn sembled
4 Servo valve stuck
Torque converter housing or transmission
36
5 Mainshaft worn/damaged
housing bearing worn/ damaged
6
Shift cable broken/out of adjustment
37
ATF strainer clogged
7 Final gears worn/damaged
Shift cable is worn where it attaches to the
One-way (sprag ) clutch worn/damaged
38
transmission or at the body mounts
B
9 1st gears worn/damaged (2 gears) 39 Modulator valve stuck
10
1st clutch defective 40 Torque converter check valve stuck
11 2nd gears worn/damaged (2 gears)
41
Foreign material in separator plate
12 2nd clutch defective 42 CPB valve stuck
13
3rd clutch defective 43 Lock-up timing valve stuck
14 4th clutch defective 44 Lock-up shift valve stuck
15 Reverse gears worn/damaged (3 gears)
45
Lock-up co ntrol valve stuck
16 Excessive A TF 46 Lock-up clutch pi ston defective
17
Torque converter one-way clutch defective
47 Shift control solenoid valve A defective
Unear solenoid assembly defective ('98 - 00
48
Shift control solenoid valve B defective
18
models)
49 Lock-up control solenoid valve A defective
19 CPC valve stuck 50 Lock-up control solenoid valve B defective
20 '-2 shift valve stuck 51
Servo control valve stuck
21
2-3 shift valve stuck
52 , st accumulator defective
22
3-4 shift valve stuck 53 Foreign material in 2nd exhaust orifice
23
2nd accumulator defective
54
Foreign material in 3rd exhaust orifice
24 3rd accum ulator defective 55 Foreign material in 4th exhaust orifice
25 4th accumulator defective 56 Mainshaft speed sensor defective
26
2nd orifice control valve stu ck
57 Counters haft speed sensor defective
27
3-4 orifice control valve stuck 58 3rd sub accumulator defective
28
Foreign material in main orifice
59
1st-hold clutch defective
29
Foreign material in 1st orifice
AfT
gear position switch defective or out of
60
adjustment
30 Foreign material in reverse orifice
31 Engine output low 61 Park gear mechanism defective
32
Needle bearing w orn/damaged
14-154