Emergency Exit Window Replacement; Trapezoidal Window Replace-Ment; Small Rear Windows Replacement - PREVOST H3-41 Maintenance Manual

FIGURE 35: FIXED WINDOW
NOTE
For all window replacement, it is extremely
important to center the top side between the
window dividing posts with great precision in
order to be able to attach the bottom of
window and the structural posts.
16.4 EMERGENCY EXIT WINDOW
REPLACEMENT
1. Lift the bar release system and follow the
same procedure mentioned above for fixed
windows.
2. Remove the stop blocks from the top
exterior of the window.
3. Reverse the procedure to install a new
emergency exit window.
FIGURE 36: EMERGENCY WINDOW
16.5 TRAPEZOIDAL WINDOW REPLACE-
MENT
Apply procedure for fixed window replacement
described in this
variations:
18434
• The angle at which the window will detach is
considerably smaller (about 45
• These windows are also glued to the
structure at certain areas on their perimeter.
Note where adhesives are used and apply
gluing techniques at these areas to complete
replacement of these windows.
16.6 SMALL REAR WINDOWS
REPLACEMENT
These small windows are located at the vehicle's
rear end, just forward of the lavatory.
Apply procedure for fixed window replacement
described in this
variations:
• The angle at which the window will detach is
considerably smaller (about 45
• These windows are also glued to the
structure at certain areas on their perimeter.
Note where adhesives are used and apply
gluing techniques at these areas to complete
replacement of these windows.
Both the trapezoidal windows and the small rear
window are fixed in place with adhesives. They
are not serviceable, in the event that they may
need replacement.
PA1621 Maintenance Manual All Series
SECTION 18a: H3 SERIES BODY
section but with these
);
o
section but with these
);
o
|
Revised Sept 2019
18435
45