Cadillac 60 Series 1963 Shop Manual page 603

INDEX
Subject Page No. Subject
Page No.
Electrical System (Cont'd.)
Generator (Cont'd.)
Inspection, Testing and Replacement
of Components 12-25
Installation 12-28
Removal 12-24
Guide-Matic:
Adjustment:
Dim Sensitivity on Car 12-85
Hold Sensitivity on Car 12-85
Amplifier Unit:
Disassembly and Assembly 12-86
Removal and Installation 12-86
Tube Replacement 12-86
Design Features 12-82
Diagnosis . 12-88
Operation:
Automatic 12-82
Manual 12-82
Phototube Unit:
Removal and Installation 12-87
Tube Assembly Replacement . . . . 12-87
Power Relay Unit, Removal and
Installation 12-87
Preliminary Checks . . . . . . . . . . 12-82
Service Corrections, Minor 12-88
Service Information 12-82
Test:
Dim Sensitivity on Car 12-84
Hold Sensitivity on Car 12-84
Vertical Aiming Procedure 12-84
Headlamp Aiming:
Mechanical Aimer Method 12-34
Screen Method. 12-35
Horn Contact Assembly, Removal and
Installation
?
. . 12-45
Horn Operation and Testing 12-44
Ignition:
Coil Test 12-18
Primary Circuit Resistance Test . . . 12-18
Timing Adjustment 12-17
Lamp, Removal and Installation:
Back-Up, Tail, Stop and Signal Lamp . 12-39
Cornering Lamp 12-40
Front Turn Signal and Parking Lamp . 12-38
Tail Light Assembly (Fender) 12-40
Oil Pressure Indicator Service 12-43
Primary Wiring Insulation Test 12-32
Radio and Antenna:
Adjustments, Minor 12-64
AM-FM Radio 12-61
Antenna:
Disassembly and Assembly 12-67
Maintenance and Repair Procedure . 12-67
Removal and Installation . . . . . . . 12-66
Controls:
Operation 12-62
Rear Seat Remote, 75 Series
Removal and Installation 12-66
Electrical System (Cont'd.)
Controls (Cont'd.)
Design Features 12-61
Diagnosis 12-69
FM-AM Radio , . . 12-61
Noise Suppressors 12-63
Receiver Unit, Removal and
Installation 12-65
Repair Procedures, Minor 12-64
Signal Seeking Tuner . 12-62
Speaker, Removal and Installation:
Front 12-65
Rear, Convertibles 12-65
Rear (Other than Convertibles) . . . 12-65
Regulator:
Contact Points Cleaning 12-31
Mechanical Adjustments 12-31
Tests and Adjustments 12-29
Sealed Beam Unit Replacement 12-36
Secondary Efficiency Test 12-17
Spark Plug,.Cleaning and Adjustment . . 12-21
Specifications 12-100
Specifications, Torque 12-90
Speedometer Head Assembly:
Disassembly and Assembly 12-42
Removal and Installation 12-42
Starter Motor:
Amperage Draw Test 12-9
Assembly and Installation 12-12
Checking Pinion Clearance 12-9
Circuit 12-8
Circuit Resistance Test 12-8
Interpretation of No-Load and
Resistance Tests 12-10
Maintenance 12-8
Test . 12-10
Removal and Disassembly 12-11
Temperature Gage Service 12-42
Windshield Wiper and Washer Unit
Removal, Disassembly, Assembly
and Installation 12-56
Wiper and Washer:
Design Features 12-47
Diagnosis Chart 12-59
Removal and Installation:
60 and 62 Series 12-51
75 and Commercial Chassis 12-76
Wiper Unit Checking Procedures:
On Bench 12-57
On Car 12-56
Wiper Unit, Disassembly and Assembly . 12-52
SECTION 13
HEATING AND AIR CONDITIONING
Air Conditioner:
Assembly, Removal and Installation
13-57