INDEX
Subject
Page No.
Subject
Page No.
Engine, Fuel and Exhaust (Cont'd.)
Heat Control Valve, Removal and
Installation
10-6
Muffler, Removal and Installation . . . .
10-5
Outlet Pipe, Removal and Installation . .
10-4
Positive Crankcase Ventilator Valve,
Removal, Cleaning and Installation . .
10-3
Rear Intermediate Pipe, Removal and
Installation
10-4
Resonator, Removal and Installation . . .
10-4
Storage Precautions
10-7
Throttle Check Valve, Removal and
Installation
10-10
Throttle Check Valve and Relay
Assembly, Removal and Installation . .
10-11
SECTION 11
ENGINE, COOLING
Engine Cooling
Diagnosis Chart
11-7
Fan Blade and Clutch Assembly,
Removal and Installation,Air
Conditioned Cars
11-7
Filler Cap, Radiator, Removal. . . . .
11-2
Flushing Procedure
11-3
General Description
11-1
Preventive Maintenance
11-2
Radiator Assembly, Removal and
Installation
11-3
Service Information
11-2
Specifications
11-8
Tests:
Ethylene Glycol Based Solutions
. .
11-2
Flow Test for Radiator Clogging . .
11-3
Radiator and Cap Leak Check . . . .
11-2
Radiator Thermostat Test
11-3
Thermostat, Removal and Installation .
11-3
Torque Specifications
11-9
Water Pump, Removal and Installation
Air Conditioned Cars
11-6
Non-Air Conditioned Cars . . . . . .
11-5
SECTION 12
ELECTRICAL SYSTEM INCLUDING
RADIO, CRUISE CONTROL AND
GUIDE-MATIC
Accessory Ground Circuit Test
12-32
Back-Up Light Switch Service
12-47
Electrical System (Cont'd.)
Battery:
Care When Not In Use
12-8
Causes of Undercharged Condition. . .
12-6
Filling Instructions
12-4
Hydrometer Test
12-6
Light Load Test
12-5
Removal and Installation
12-7
Use of Hydrometer
12-5
Visual Inspection
12-7
Bulb Data Chart
12-99
Bulb Replacement
12-37
Bulb Replacement, Instrument Panel. . .
12-38
Charging Circuit:
Analyzing Troubles .
12-21
Precautions
12-21
Preliminary Checks
12-21
Testing Indicator Lamp Circuit . . . .
12-22
Testing Undercharged Battery
Condition
12-22
Clock:
Regulation and Resetting
12-46
Removal and Installation
12-46
Cruise Control:
Control Cable Adjustment
12-79
Diagnosis
12-76
Diagnosis Chart
12-80
General Description
12-70
Power Unit:
Disassembly and Assembly
12-72
Removal and Installation
12-72
Linkage Adjustment
12-79
Locking Arm Latch and Grounding
Adjustments (On Car)
12-78
Omni-Switch Adjustment
12-79
Selector Dial Calibration
12-95
Service Information
12-71
Distributor:
Assembly and Installation
12-16
Condenser Tests
12-20
Contact Points
12-13
Test Information
12-15
Removal and Disassembly
12-15
Directional Signal:
Operation
12-43
Switch, Removal and Installation . . . .
12-44
Electrical Accessory Installation
. . . .
12-44
Engine Tests
12-33
Fuel Gage Service
12-40
Fuel Gage Tank Unit, Removal and
Installation
12-41
Fuel or Temperature Gage Removal. . .
12-42
Fuse and Circuit Breaker Locations. . .
12-90
General Description
12-2
Generator:
Assembly
12-28
Belt Adjustment
12-28
Disassembly
12-24