Troubleshooting; Sunroof Panel Height Adjustment - Honda Prelude 1993 Service Manual

Troubleshooting
Symptom
Probabla Causo
Water leaks 1 .
J .
4 .
Clogged drain tube.
Gap between sunroof sealand rooJ panel.
Defective or improperly installed sunroof seal.
GaD betwa€n frame sealand roof Danel,
Wind noise
1 . Excessive cleSrance betwaen sunroof seal and roof Danel,
Motor noise
1, Loose motor.
2. Worn gear or besring.
3. Outer cable deformed,
Sunroof Danal does not move, but
motor turns
1 .
a
4.
Clutch out of adjustment.
Foreign matter stuck b€twoen guide rail and slider,
lnner cable loos€.
Outer cable not attached properly.
Sunroof Danel do€s not move and
motor does not turn lsunroof panel
can be moved with sunroot wrench)
1. Blown tuse.
2. Fauhy switch.
3. Battery run down,
4. D€tective motor,
5. Fsulty relay.
Sunroof Panel Height Adjustment
Boot panel should be even with the sunroof seal to
within 1.9 t
0.5 mm (0.o7 + 0.02 in) 8ll the w8y
around. lf not, tih the sunloot panelfully, and:
SUNROOF SEAL
Remove ths sunroof liner (see page 2G3O).
Loosen the sunroof panel mounting nuts and
instsll shims between sunroof panel and panel
bracket as shown.
Shlm thlcknos!:
1.O mm (O.O4 in)
Adlustmont: max. 2.0 mm (0.O8 in)
Repeat on opposite sids if necessary.
PANEL BRACKET
1 .
20-29
1.9 t o.5 mm
ROOF pA EL
{0.07 t O.02Inl
SHIMS