Table of Contents
Advertisement
WARNING:
For vehicles equipped with Supplemental Restraint (Air Bag) System:
D Service on and around the air bag system components or wiring must be performed only by an autho-
rized SUZUKI dealer. Refer to "Air Bag System Components and Wiring Location View" under "Gener-
al Description" in air bag system section in order to confirm whether you are performing service on
or near the air bag system components or wiring. Please observe all WARNINGS and "Service Precau-
tions" under "On-Vehicle Service" in air bag system section before performing service on or around
the air bag system components or wiring. Failure to follow WARNINGS could result in unintentional
activation of the system or could render the system inoperative. Either of these two conditions may
result in severe injury.
D Technical service work must be started at least 90 seconds after the ignition switch is turned to the
"LOCK" position and the negative cable is disconnected from the battery. Otherwise, the system may
be activated by reserve energy in the Sensing and Diagnostic Module (SDM).
GENERAL INFORMATION AND ENGINE DIAGNOSIS
ENGINE MECHANICAL
ENGINE COOLING
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ENGINE FUEL
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ENGINE AND EMISSION CONTROL SYSTEM
IGNITION SYSTEM
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
CRANKING SYSTEM
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
CHARGING SYSTEM
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GENERAL INFORMATION
Statement on Cleanliness and Care
General Information on Engine Service
Precaution on Fuel System Service
Fuel Pressure Relief Procedure
Fuel Leakage Check Procedure
ENGINE DIAGNOSIS
. . . . . . . . . . . . . . . . . . .
General Description
. . . . . . . . . . . . . . . . . . .
On-Board Diagnostic System
Precaution in Diagnosing Trouble
Engine Diagnostic Flow Table
Customer Problem Inspection From
Malfunction Indicator Lamp Check
Diagnostic Trouble Code Check
Diagnostic Trouble Code Clearance
Diagnostic Trouble Code Table
SECTION 6-1
GENERAL INFORMATION
AND ENGINE DIAGNOSIS
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
CONTENTS
. . . . . . . . . . . . . .
6-1- 3
. . . . .
6-1- 3
. .
6-1- 3
. . . . .
6-1- 4
. . . . . . . .
6-1- 5
. . . . . . . .
6-1- 5
6-1- 6
6-1- 6
. . . . . . . . . .
6-1- 6
. . . . . . .
6-1- 9
. . . . . . . . . .
6-1-10
. . . . .
6-1-12
. . . . . .
6-1-13
. . . . . . . .
6-1-13
. . . . .
6-1-14
. . . . . . . . .
6-1-15
GENERAL INFORMATION AND ENGINE DIAGNOSIS 6-1-1
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fail-safe Table
. . . . . . . . . . . . . . . . . . . . . . .
Visual Inspection
. . . . . . . . . . . . . . . . . . . . .
Engine Basic Inspection
Engine Diagnosis Table
Scan Tool Data
. . . . . . . . . . . . . . . . . . . . . . .
Scan Tool Data Definitions
Inspection of ECM (PCM) and Its
Circuits
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Voltage Check
. . . . . . . . . . . . . . . . . . . . .
Resistance Check
Component Location
Table A-1 MIL Circuit Check
(Lamp does not come on)
Table A-2 MIL Circuit Check
(Lamp remains ON)
Table A-3 ECM (PCM) Power and
Ground Circuit Check
6-1-1
6A-1
6B-1
6C-1
6E1-1
6F-1
6G2-1
6H-1
6-1-17
6-1-18
. . . . . . . . . . . . . . .
6-1-19
. . . . . . . . . . . . . . .
6-1-21
6-1-28
. . . . . . . . . . . . .
6-1-30
6-1-32
6-1-32
. . . . . . . . . . . . . . . . . .
6-1-36
. . . . . . . . . . . . . . . . . .
6-1-37
. . . . . . . . . . . .
6-1-38
. . . . . . . . . . . . . . . . . .
6-1-39
. . . . . . . . . . . . . . . .
6-1-40
6-1
- Quick Links:
- Table of Contents
- Engine Coolant Change
Hide quick links:
Advertisement
Chapters
Table of Contents
