Daihatsu F300 Service Manual page 1082

APPENDIX
• STEERING
Tightening component N·m kgf-m
ft-lb
Steering gear housing x 011 filler plug
2.0-3.9 0.2- 0.4 1.4-2.9
(Except powt::r steering equipped model)
Steering gear box x Pressure tubes
39.2-49.0
4.0-5.0 28.9- 36.2
(Only power steering equipped model)
Steering wheel x Steering shaft
29.4- 49.0 3.0-5.0 21.7. 36.2
Steering shaft x Intermediate shaft 24.5-34.3 2.5-3.5 18.1-25.3
Steering hole cover x Floor panel 3.9-6.9 0.4-0.7 2.9-5.1
Steering colum tube x Brace (Instrument panel) 14.7-21.6 1.5-2.2
10.8- 15.9
Steering colum tube
x
Steering hole cover
3.9-6.9
0.4- 0.7
2.9-5.1
(Tilt steering ezuipped model only)
Steering support x long nut
12.7 1.3 9.4
(Tilt steering equipped model only)
•
Steering lever
x
long nut
29.4- 49.0
3.0-4.5
21.7-36.2
(Tilt
steering
equipped model only) 24.5-34.3 2.5-3.5
18.1 - 25.3
Steering relay rod x Tie rod 68.6- 137 7.0-14.0 50.6- 101
Idler arm support pin x Frame 34.3-53.9 3.5-5.5 25.4- 39.6
Idler arm support pin x Idler arm assembly
106- 167 12.0- 17.0 87- 123
Idler arm x Relay rod
49.0-68.6 5.0-7.0 36.2- 50.6
Pitman arm x Relay rod
68.6- 137 7.0- 14.0 50.6- 101
Tie rod x Steering knuckles
68.6- 137
7.0- 14.0
68.6- 137
Wheel hub nuts 88.3-118 9.0- 12.0 65.1 - 87.0
Steering gear housing x Frame
73.5- 103 7.5- 10.5 54.2-75.9
Steering gear housing x Pitman arm 147-196 15.0-20.0 109- 145
Cross shaft adjust screw x Lock nut
19.6-34.3 2.0- 3.5 14.5- 25.3
Intermediate shaft x Steering gear housing 24.5-34.3 2.5-3.5 18.1 - 25.3
•
Idle pulley x Vane pump bracket
34.3-49.0 3.5-5.0 25.3-36.2
Vane pump x Pump front stay
34.3-49.0
3.5-5.0 25.3-36.2
Vane pump x Pulley 34.3-53.0 3.5-5.4 25.3-39.1
Vane pump bracket x Engine M8 9.8-15.7 1.0- 1.6 7.2-11.6
M10 34.3- 44.1 3.5-4.5 25.3-32.5
Pump front stay x Tube support bracket 9.8- 15.7 1.0- 1.6 7.2- 11.6
Tube support bracket x Clamp 3.9- 6.9 0.4-0.7 2.9-5.1
Vane punp x Union bolt
44.1 - 53.9 4.5-5.5 32.5-39.8
Tube support brake! x Tube support bracket
9.8- 15.7 1.0-1.6 7.2- 11.6
Drive belt tension adjust bolt x Lock nut
9.8- 15.7 1.0-1.6 7.2- 11.6
Vane pump front stay x Adjusting strut
34.3- 44.1 3.5-4.5 25.3-32.5
Adjusting strut x Adjusting bar
68.6-88.3 7.0-9.0 50.6- 65.1
Vane pump x Vane pump bracket
49.0-68.6
5.0-7.0
36.2-50.6
•
A-19'