Goldacres G6 Crop Cruiser 2 Series Operator's Manual page 191

Transmission oil filter.
6 Install the filter by hand, until the gasket
touches the housing.
Turning the filter more than one full turn
after gasket contact will damage it. Turn
the filter ONE FULL TURN ONLY after
gasket contact.
8 Refill transmission with oil.
Refer to the oil & filter specification
provided in the 'Maintenance Schedules'
of this chapter.
Refer to the Allison Transmission Operation & Codes
Manual (supplied) for any information on the operation
and/or troubleshooting of the Allison transmission.
GA8701177 REV 2 APRIL 2022
Integrated transmission oil cooler.
Transmission Oil Cooler
The transmission oil cooler is integrated within
the engine radiator.
Driveline & Differential Maintenance Schedules are
provided in the 'Maintenance Schedules' of this chapter.
Lubrication & Maintenance – Service
Inspect & grease fixed drivelines regularly.
Fixed Drivelines
Fixed Drivelines transmit drive between the
transmission and the differentials.
Each driveline has greasable universal joints at
each end & centre bearings on the shafts.
The rear shaft also has a telescopic spline
which requires greasing.
All fixed drivelines should be inspected for
wear & greased at regular service intervals.
Refer to the 'Grease Points' & 'Maintenance
Schedules' in this chapter.
Inspect & grease fixed drivelines regularly.
Clean the breather of differentials regularly.
Differentials
Differentials run in an oil bath sump.
The oil level can be checked by removing
the level plug on the side of the differential
housing.
The oil should be replaced at the first service
to remove manufacturing contamination. The
oil must be replaced every 500 hours.
Refer to the specification provided in the
'Maintenance Schedules' of this chapter.
A breather, located on the top of the
differential, allows oil to expand and contract
without creating a vacuum or pressurising the
differential housing.
Differential breathers must be cleaned at
regular service intervals.
Rear differentials are fitted with an LSD. Some chattering
noise may be present during first use, but will subside over
time. This is normal.
8
191