Subaru Legacy 2002 Service Manual page 2269

Power Assisted System (Power Steering)
E: INSPECTION
1. BASIC INSPECTION
1) Clean all disassembled parts, and check for wear, damage, or any other faults, then repair or replace
as necessary.
2) When disassembling, check inside of gearbox for water. If any water is found, carefully check boot for
damage, input shaft dust seal, adjusting screw and boot clips for poor sealing. If faulty, replace with new
parts.
No. Parts
1 Input shaft
2 Dust seal
3 Rack and pinion
4 Gearbox unit
5 Boot
6 Tie-rod
7 Tie-rod end
8 Adjusting screw spring
9 Boot clip
10 Sleeve
11 Pipes
STEERING GEARBOX [RHD MODEL]
S601276A10
S601276A1001
Inspection
(1) Bend of input shaft
(2) Damage on serration
(1) Crack or damage
(2) Wear
Poor mating of rack with pinion
(1) Bend of rack shaft
(2) Bend of cylinder portion
(3) Crack or damage on cast
iron portion
(4) Wear or damage on rack
bush
(5) Wear on input shaft bearing
Crack, damage or deterioration
(1) Looseness of ball joint
(2) Bend of tie-rod
Damage or deterioration on dust
seal
Deterioration
Deterioration
Damage
(1) Damage to flared surface
(2) Damage to flare nut
(3) Damage to pipe
If bend or damage is excessive, replace entire
gearbox.
If outer wall slips, lip is worn out or damage is
found, replace it with new one.
(1) Adjust backlash properly.
By measuring turning torque of gearbox and sliding
resistance of rack, check if rack and pinion engage
uniformly and smoothly with each other.
(Refer to "Service limit".)
(2) Keeping rack pulled out all the way so that all
teeth emerge, check teeth for damage.
Even if abnormality is found in either (1) or (2),
replace entire gearbox.
Replace gearbox with new one.
If free play of rack shaft in radial direction is out of
the specified range, replace gearbox with new one.
(Refer to "Service limit".)
If free plays of input shaft in radial and axial direc-
tions are out of the specified ranges, replace gear-
box with new one.
(Refer to "Service limit".)
Replace.
Replace.
Replace.
Replace.
Replace.
Replace.
Replace.
PS-60
Corrective action