Dtc P1603: Tcm Trouble Code Detected - Suzuki Swift Sport 2004 Service & Repair Manual

1A-144 Engine General Information and Diagnosis:
DTC Troubleshooting
NOTE
• When measuring circuit voltage, resistance and/or pulse signal at ECM connector, connect the
special tool to ECM and/or the ECM connectors referring to "Inspection of ECM and Its Circuits".
• Upon completion of inspection and repair work, perform "DTC Confirmation Procedure" and
confirm that the trouble has been corrected.
Step
1 Was "Engine and Emission Control System Check"
performed?
2 Battery voltage supply circuit check
1) Turn OFF ignition switch.
2) Remove ECM from its bracket with ECM connectors
connected.
3) With engine running, measure voltage between "E23-2"
terminal of ECM connector and engine ground.
Is voltage 10 – 14 V?

DTC P1603: TCM Trouble Code Detected

Wiring Diagram
15 14 13 12 11
30 29 28 27 26
44
45 43 42 41
60 59 58 57 56
1. ECM
DTC Detecting Condition
When ECM receives a trouble code from TCM, which indicates that some problem occurred in sensor circuits and its
calculated values used for operations such as idle speed control, engine power control, and so on by TCM, ECM sets
DTC P1603. (TCM outputs the trouble code to ECM when TCM can not compute the engine control signal due to
malfunctions of sensor circuits used for gear shift control.)
Action
2
C34-17 RED
C34-7 WHT
E23
10 9 8 7 6 5 4 3
25 24 23 22 21 20 19 18
40 39 38 37 36 35 34 33
55 54 53 52 51 50 49 48
Go to Step 2.
Poor "E23-2"
connection or
intermittent trouble.
Check for intermittent
referring to "Intermittent
and Poor Connection
Inspection in Section
00".
If wire and connections
are OK, substitute a
known-good ECM and
recheck.
RED C37-13
WHT C37-12
2 1 15 14 13 12 11
17 16 30 29 28 27 26
44
32 31 45 43 42 41
47 46 60 59 58 57 56
2. TCM (for A/T model)
Yes
Go to "Engine and
Emission Control
System Check".
"RADIO" fuse blown,
"WHT" or "WHT/RED"
wire is circuit open or
short circuit.
1
C37
10 9 8 7 6 5 4 3
25 24 23 22 21 20 19 18
40 39 38 37 36 35 34 33
55 54 53 52 51 50 49 48
No
S7RS0B1104061
2 1
17 16
32 31
47 46
I6RS0C110026-01