Pressure Control Solenoid Valves (Pressure Control Solenoid And Tcc Pressure Control Solenoid) Removal And Installation; Pressure Control Solenoid Valve Inspection - Suzuki Swift Sport 2004 Service & Repair Manual

Pressure Control Solenoid Valves (Pressure
Control Solenoid and TCC Pressure Control
Solenoid) Removal and Installation
Removal
1) Disconnect negative cable at battery.
2) Lift up vehicle.
3) Remove drain plug and drain A/T fluid.
4) Install drain plug.
Tightening torque
A/T fluid drain plug: 17 N·m (1.7 kgf-m, 12.5 lb-ft)
5) Remove A/T oil pan (1) and oil pan gasket (2).
6) Remove oil strainer assembly (3).
7) Remove transmission fluid temperature sensor (1)
from sensor clamp.
8) Disconnect solenoid connectors (2).
1
9) Remove valve body assembly referring to
"Automatic Transaxle Unit Disassembly".
10) Remove pressure control solenoid valve and TCC
S7RS0B5106024
pressure control solenoid valve referring to "Valve
Body Assembly Disassembly and Reassembly".
Installation
Reverse removal procedure to install pressure control
solenoid valve and valve body assembly noting the
following points.
• For detail of pressure control solenoid valve and TCC
pressure control solenoid valve installation, refer to
"Valve Body Assembly Disassembly and
Reassembly".
• For detail of valve body assembly installation, refer to
"Automatic Transaxle Unit Assembly".
• For detail of installing wire harness for solenoid valves
and sensor, refer to "Automatic Transaxle Unit
Assembly". Use new O-rings.
• For detail of A/T oil pan and oil strainer assembly
installation, refer to "Automatic Transaxle Unit
Assembly". Use new oil pan gasket.
• Pour A/T fluid and check fluid level according to
procedure described in "A/T Fluid Change".
• Check for fluid leakage after warming up A/T.

Pressure Control Solenoid Valve Inspection

!
• Be very careful as dust etc. does enter
Resistance Check
Measure resistance between pressure control solenoid
valves (Pressure control solenoid and TCC pressure
I2RH0B510054-01
control solenoid) (1) terminals.
Pressure control solenoid valve and TCC pressure
control solenoid valve resistance
Standard: 5.0 – 5.6 Ω at 20 °C (68 °F)
2
I4RS0A510027-01
Automatic Transmission/Transaxle:
CAUTION
when pressure control solenoid valves are
inspected.
1
5A-101
S7RS0B5106025
I2RH01510071-01