Propellers; Volvo Duo Prop Removal - Regal 3760 Owner's Manual

PROPELLERS

Out-of-balance or nicked props will effect performance
or cause vibration. Damaged props should be replaced,
but those that are chipped or bent can usually be
reconditioned by a marine dealer or a propeller repair
facility. When cruising, consider carrying a spare set of
props on board because many marinas do not carry a full
inventory of replacement propellers. Refer to the
manufacturer's engine manual for appropriate stern drive
propeller replacement.
Be sure to make a note of the propeller diameter and
pitch while the vessel is in dry dock. They are pressed
into the prop for easy reading.
Make sure the ignition keys are out of the ignition switch
and the battery switch in the "off " position before
attempting to remove or install propellers.
It is recommended that you wear a pair of leather gloves
to protect yourself from sharp propeller blades. With dual
propeller units you may be able to use a piece of wood
between the top of the gear housing and the propeller to
hold it from turning while you are removing the prop nuts
and hardware to access the props. Some of these units
use 2 lock nuts, one for each propeller. You may need a
special socket and rachet set to remove the propeller nuts.
Line up the hardware according to its disassembly for
reassembly purposes. Refer to the drawings on the
following pages showing selected propeller shaft hardware.
See the engine manufacturer's owners manual for further
information.

Volvo Duo Prop Removal

Special tools are recommended to remove both propellers
from the propeller shaft (Volvo P/N 3855516).
1. The ignition key must be in the off position along with
the battery switch.
2. Shift the remote control to the forward position to lock
the propeller shaft.
3. Remove the aft propeller nut.
4. Remove the aft propeller.
5. Shift the remote control to reverse to lock the propeller
shaft.
6. Remove the front propeller nut.
7. Remove the front propeller.
8. Clean the propeller shaft by wiping it off and inspect
for any fish line.
64
Chapter 8