Subaru LEGACY 2006 Manual page 79

asieps_tobira.book 28 ページ ２００９年１０月２６日 月曜日 午前９時１６分
COOLING
11.Engine Cooling System Trouble in General
A: INSPECTION
Trouble
a. Insufficient engine coolant
b. Loose timing belt
c. Oil on timing belt
d. Malfunction of thermostat
e. Malfunction of water pump
f. Clogged engine coolant passage
g. Improper ignition timing
Overheat
h. Clogged or leaking radiator
i. Engine oil mixed in engine coolant
j. Air/fuel mixture ratio too lean
k. Excessive back pressure in exhaust system
l. Insufficient clearance between piston and cylinder
m. Slipping clutch
n. Dragging brake
o. Defective radiator fan
a. Ambient temperature extremely low
Over-cooling
b. Defective thermostat
a. Loosened or damaged connecting units on hoses
b. Leakage from water pump
c. Leakage from water pipe
Engine coolant
d. Leakage around cylinder head gasket
leaks
e. Cylinder head and block damaged or cracked
f. Damaged or cracked thermostat case
g. Leakage from radiator
a. Timing belt problem
b. Defective radiator fan
Abnormal noise
c. Defective water pump bearing
d. Defective water pump mechanical seal
Engine Cooling System Trouble in General
Possible cause
CO(H4SO)-28
Corrective action
Replenish engine coolant, inspect for leakage, and
repair it if necessary.
Repair or replace timing belt tensioner.
Replace.
Replace.
Replace.
Clean.
Inspect and repair ignition control system.
<Ref. to EN(H4SO)(diag)-2, Basic Diagnostic Proce-
dure.>
Clean, repair or replace.
Replace the engine coolant.
Inspect and repair the fuel injection system. <Ref. to
EN(H4SO)(diag)-2, Basic Diagnostic Procedure.>
Clean or replace.
Adjust or replace.
Correct or replace.
Adjust.
Inspect the radiator fan relay, engine coolant tempera-
ture sensor or fan motor and replace them.
Partly cover radiator front area.
Replace.
Correct or replace.
Replace.
Correct or replace.
Retighten the cylinder head bolts or replace the gasket.
Correct or replace.
Correct or replace.
Correct or replace.
Replace.
Replace.
Replace water pump.
Replace water pump.