Table of Contents
Advertisement
WARNING:
For vehicles equipped with Supplemental Restraint (Air Bag) System :
• Service on and around the air bag system components or wiring must be performed only by an
authorized SUZUKI dealer. Refer to "System Components and Wiring Location View" under "Gen-
eral Description" in Section 10B in order to confirm whether you are performing service on or near
the air bag system components or wiring. Please observe all WARNINGS and "Service Precautions"
under "On-Vehicle Service" in Section 10B before performing service on or around the air bag sys-
tem components or wiring. Failure to follow WARNINGS could result in unintentional activation of
the system or could render the system inoperative. Either of these two conditions may result in
severe injury.
• Technical service work must be started at least 90 seconds after the ignition switch is turned to the
"LOCK" position and the negative cable is disconnected from the battery. Otherwise, the system
may be activated by reserve energy in the Sensing and Diagnostic Module (SDM).
General Description ........................................7B-3
Specifications ................................................ 7B-5
Clutch/Brake/Planetary Gear ........................ 7B-6
Functions................................................... 7B-6
Table of Component Operation..................... 7B-7
Electronic Shift Control System..................... 7B-8
Transmission Control Module (TCM) .......... 7B-10
Operation of shift solenoid valves,
timing solenoid valve and TCC
solenoid valve.......................................... 7B-11
Automatic gear shift diagram................... 7B-12
Diagnosis .......................................................7B-13
General Description .................................... 7B-13
On-board Diagnostic System ...................... 7B-14
Precaution in Diagnosing Trouble ............... 7B-15
Automatic Transaxle Diagnostic Flow
Table ........................................................... 7B-16
"O/D OFF" Lamp Check .............................. 7B-20
Malfunction Indicator Lamp (MIL)
Check .......................................................... 7B-20
Diagnostic Trouble Code (DTC) Check....... 7B-20
Diagnostic Trouble Code (DTC)
Clearance.................................................... 7B-21
Diagnostic Trouble Code (DTC) Table........ 7B-22
Fail Safe Table ............................................ 7B-24
Visual Inspection ......................................... 7B-26
Automatic Transaxle Basic Check .............. 7B-27
Trouble Diagnosis Table ............................. 7B-28
Trouble diagnosis table-1 ........................ 7B-28
Trouble diagnosis table-2 ........................ 7B-31
Trouble diagnosis table-3 ........................ 7B-33
SECTION 7B
AUTOMATIC TRANSAXLE
CONTENTS
Road Test ................................................... 7B-34
Manual Road Test....................................... 7B-37
Engine Brake Test ...................................... 7B-38
Stall Test ..................................................... 7B-39
Time Lag Test ............................................. 7B-40
Line Pressure Test...................................... 7B-41
"P" Range Test............................................ 7B-42
Diagnostic Flow Table A-1: No Gear
Shift to O/D ................................................. 7B-43
Diagnostic Flow Table A-2: No Lock-Up
Occurs......................................................... 7B-44
Diagnostic Flow Table A-3: "O/D OFF"
Lamp Circuit Check ("O/D OFF" Lamp
Lights Steadily) ........................................... 7B-45
Diagnostic Flow Table A-4: "O/D OFF"
Lamp Circuit Check ("O/D OFF" Lamp
Does Not Light Anytime) ............................. 7B-47
Diagnostic Flow Table A-5: TCM Power
and Ground Circuit Check........................... 7B-48
DTC P0705 Transmission Range Sensor
Circuit Malfunction ...................................... 7B-50
DTC P0707 Transmission Range Sensor
Circuit Low .................................................. 7B-53
DTC P0712 Transmission Fluid
Temperature Sensor Circuit Low ................ 7B-56
DTC P0713 Transmission Fluid
Temperature Sensor Circuit High ............... 7B-58
DTC P0717 Input/Turbine Speed Sensor
Circuit Malfunction ...................................... 7B-60
DTC P0722 Output Speed Sensor (VSS)
Circuit No Signal ......................................... 7B-62
AUTOMATIC TRANSAXLE 7B-1
6E1
7A2
7B
8C1
8G3
9
Advertisement
Table of Contents
