Periodic Service Schedules - Club Car Turf 252 2007 Maintenance And Service Manual

PERIODIC MAINTENANCE
programmed speed. On very steep grades, the vehicle may slightly exceed its maximum programmed speed,
requiring use of the brake pedal.
Gasoline Vehicles
• Accelerator for pedal-start vehicle: With the key switch in the ON position and the Forward/Reverse handle in the
FORWARD position, as the accelerator pedal is pressed, the engine should start and the vehicle should accelerate
smoothly to full speed. When the pedal is released it should return to the original position and the engine should
stop. Club Car vehicles operate at reduced speed in reverse.
• Accelerator for key-start vehicle: After starting the engine with the key switch and placing the Forward/Reverse
handle in the FORWARD position, the vehicle should accelerate smoothly to full speed as the accelerator pedal is
pressed. When the accelerator pedal is released it should return to the original position and the engine should idle.
• Governor: Check maximum speed of the vehicle. The gasoline Turf 252 and Carryall 252 should operate at
15-17 mph (24-27 km/h) on a level surface. The gasoline XRT 900 should operate at 17-19 mph (27-31 km/h)
on a level surface. Turf 252 and Carryall 252 electric vehicles should operate at a standard speed of 15-17 mph
(24-27 km/h) on a level surface. They can be adjusted to a maximum speed of 17-19 mph (27-31 km/h) on a level
surface. XRT 900 electric vehicles can be set at the factory to operate at either 15-17 mph (24-27 km/h) or to
17-19 mph (27-31 km/h) on a level surface.

PERIODIC SERVICE SCHEDULES

See General Warning on page 1-1.
WARNING
• Service, repairs, and adjustments must be made per instructions in the maintenance and service
manual.
• If any problems are found during scheduled inspection or service, do not operate the vehicle until
repairs are made. Failure to make necessary repairs could result in fire, property damage, severe
personal injury, or death.
NOTE: If the vehicle is constantly hauling heavy loads or hauling a trailer, these preventive maintenance procedures
should be performed more often than recommended in the Periodic Service Schedule.
Both the Periodic Service Schedules and the Periodic Lubrication Schedules must be followed to keep
vehicle in optimum operating condition.
2007-2009 Turf 252, Carryall 252 and XRT 900 Maintenance and Service Manual
Periodic Service Schedules
Page 10-3
10