Battery Troubleshooting Chart - Club Car Turf 252 2007 Maintenance And Service Manual

BATTERIES: ELECTRIC VEHICLES

BATTERY TROUBLESHOOTING CHART

All readings below 5.25 V but within 0.5 V
Possible old batteries.
Go to hydrometer testing.
Replace any battery with a variation
of more than 50 points of specific gravity
between cells or has a cell with no
reading at all.
2007-2009 Turf 252, Carryall 252 and XRT 900 Maintenance and Service Manual
V ehicle not operating to expectation.
Battery Charger T
Reading below 6 amps and on-charge
voltage above 56 volts.
On-Charge V oltage T est
Any reading below 5.25 V and not
within 0.5 V of those batteries
above 5.25 V , replace battery .
Entire battery set with specific gravity
readings below 1.250 is being
consistently undercharged.
Evaluate charging practices.
If discharge time is less than 60 minutes,
replace all batteries below 5.0 V .
Figure 25-3 Battery Troubleshooting Chart
Fully Charge Batteries.
est
Battery Troubleshooting Chart
Reading of 6 amps or more.
Check electrical system and charger
for problems.
SeeTroubleshooting Guide
If problem is not found, go to
on-charge voltage test.
All readings above 5.25 V and within 0.5 V .
Hydrometer T est
No apparent problems.
Discharge T est
If discharge time is 60 minutes or
more, problem is not with the batteries.
25
Page 25-7