Receptacle Fuse Link; Receptacle Fuse Link Removal - Club Car Turf 252 2007 Maintenance And Service Manual

ELECTRICAL COMPONENTS: ELECTRIC
VEHICLES

RECEPTACLE FUSE LINK

The fuse link on the 48-volt Club Car electric vehicle should not blow under normal operating conditions; however, if
the fuse link has blown, the vehicle will not charge and the fuse must be replaced. The fuse link (6) is mounted on top
of the charger receptacle in the battery compartment (Figure 24-11, Page 24-15).

RECEPTACLE FUSE LINK REMOVAL

1. Disconnect the batteries and discharge the controller. See Disconnecting the Batteries – Electric Vehicles,
Section 1, Page 1-4.
2. Remove the fuse link (6) from the charger receptacle (5) by removing the two nuts and washers used to secure
the 10-gauge black wire (11) from the computer and the 10-gauge black wire to the receptacle (Figure 24-11,
Page 24-15).
3. Remove the fuse link (6) from the charger receptacle.
2007-2009 Turf 252, Carryall 252 and XRT 900 Maintenance and Service Manual
1
Figure 24-11 Charger Receptacle
Receptacle Fuse Link
6
7
11
10 9 4 8
24
Page 24-15