Fuel Gauge/Hour Meter; Fuel Gauge/Hour Meter Removal - Club Car Turf 252 2007 Maintenance And Service Manual

13

Fuel Gauge/Hour Meter

522
Figure 13-24 Fuel Gauge/Hour Meter Installation –
Mid-2007 and Newer Vehicles
FUEL GAUGE/HOUR METER
See General Warning on page 1-1.
TESTING THE FUEL GAUGE/HOUR METER
See Test Procedure 25 – Fuel Gauge on page 11-33. Also see Test Procedure 26 – Hour Meter on page 11-35.
Early to mid-2007 vehicles: With the key switch in the OFF position, the fuel gauge/hour meter fields are blank.
When the key switch is turned to ON, both fields activate. Mid-2007 and newer vehicles: With the key switch in
the OFF position, the fuel gauge field is blank; however, the hour meter field is always ON. When the key switch is
turned to ON, the fuel gauge field activates. All model years: The fuel gauge initially registers full before indicating
the actual fuel level.
The hour meter displays the number of hours of use in increments of 0.1 (one tenth) hour, but does not record
additional time unless the key switch is in the ON position and the engine is on. When recording, the hourglass
icon on the left blinks (slowly on Early 2007 vehicles).

FUEL GAUGE/HOUR METER REMOVAL

1. Disconnect battery and spark plug wire(s). See Disconnecting the Battery – Gasoline Vehicles, Section
1, Page 1-3.
2. Remove the center dash panel. See Key Switch Removal on page 13-17.
3. Disconnect the wires from the fuel gauge/hour meter (1). Do not allow wires to touch.
4. Remove the fuel gauge/hour meter.
4.1. Early to mid-2007 vehicles: Remove the two hex nuts (2) and lockwashers (3) from the threaded studs on
the back of the gauge (Figure 13-23, Page 13-25). Remove the mounting bracket (4) from the back side of
the gauge/meter and remove it from the instrument panel.
4.2. Mid-2007 and newer vehicles: Remove the mounting clip (2) that secures the gauge/meter (Figure
13-24, Page 13-26). Alternate pulling the lower and upper tabs away from the gauge housing to remove
clip. Pull gauge/meter from the instrument panel.
Page 13-26 2007-2009 Turf 252, Carryall 252 and XRT 900 Maintenance and Service Manual
1
ELECTRICAL COMPONENTS: KEY-START WITH
NEUTRAL REV GAS VEHICLE