Section 10 - Periodic Maintenance; Periodic Service Schedule - Club Car TURF 272 2005 Maintenance Service Manual

SECTION 10 – PERIODIC MAINTENANCE
ý
DANGER
• See General Warning, Section 1, Page 1-1.
ý
WARNING
• See General Warning, Section 1, Page 1-1.

PERIODIC SERVICE SCHEDULE

ý
WARNING
• Service, repairs, and adjustments must be made per instructions in this maintenance and
service manual.
NOTE: If the vehicle is constantly subjected to heavy use or severe operating conditions, the preventive
maintenance procedures should be performed more often than recommended in the periodic ser-
vice and lubrication schedules.
Both the Periodic Service Schedule and the Periodic Lubrication Schedule must be followed to
keep the vehicle in optimum operating condition.
PERIODIC SERVICE SCHEDULE
REGULAR INTERVAL SERVICE
Monthly service by
owner
or trained technician
Engine
Tires
General vehicle
Semiannual service by
Battery
trained technician only
(or every 50 hours of
operation, whichever
Front wheel alignment and toe-in
comes first)
Electrical wiring and connections
Brake system
Periodic Service Schedule continued on next page...
2005 Turf/Carryall 272/472 and XRT 1200/1200SE Gasoline Vehicle Maintenance and Service Manual
Check engine oil level; change if necessary. See Periodic
Lubrication Schedule on page 10-2.
Check engine cooling air intake; visually inspect unshrouded
area around engine exhaust for grass and debris and clean if
necessary.
Check air pressure and adjust if necessary. See Section 2 –
Vehicle Specifications.
Wash engine compartment and underside
of vehicle. Do not wash engine when hot.
Clean terminals and wash dirt from casing; check electrolyte
level. See Battery, Section 12, Page 12-28.
Check and adjust if necessary. See Wheel Alignment,
Section 7, Page 7-13.
Check for tightness and damage.
Inspect master cylinder, wheel cylinders, brake lines, and
hoses for damage or leakage.
Check park brake cables for damage; replace if necessary.
Check brake shoes and drums; replace if necessary. See
Brake System Inspection, Section 6, Page 6-1.
10
Page 10-1