Fuel Pump; General Information; Fuel Pump Removal - Club Car Turf 252 2007 Maintenance And Service Manual

S27 FE 350 FUEL SYSTEM
FUEL LINE NO.
1
2
3
4
5
6 Molded Vent tube (Fuel Tank to Canister, PN 103372501)
7
* (Turf 2 and 252, Carryall 2 and 252, Carryall 2 Plus and XRT 900)
** (Turf 6, Carryall 6, Transporter Vehicles)

FUEL PUMP

See General Warning on page 1-1.

GENERAL INFORMATION

The gasoline vehicle is equipped with an impulse fuel pump. If the fuel pump is not operating properly, perform
the following tests:
• Make sure all hose clamps are tight.
• Inspect the impulse line and fuel lines for damage or clogging.
• Make sure the air vent on the fuel pump is not clogged with dirt.
• Make sure the fuel filters are not clogged.
To clean the air vent, the fuel pump must be disassembled.

FUEL PUMP REMOVAL

1. Turn the key switch to the OFF position and remove the key, place the Forward/Reverse handle in the NEUTRAL
position, and chock the wheels.
2. Disconnect battery. See Disconnecting the Battery – Gasoline Vehicles, Section 1, Page 1-3.
3. Turn fuel shut-off valve on top of the fuel tank to the closed (OFF) position (Figure 18-18, Page 18-26 or Figure
18-19, Page 18-26).
4. Remove hardware attaching the fuel pump (24) and lift the fuel pump out of the engine compartment (Figure
18-13, Page 18-18).
5. Remove the clamp (20) and impulse line (7) from fuel pump.
2007-2009 Turf 252, Carryall 252 and XRT 900 Maintenance and Service Manual
ROUTING
Fuel tank to fuel filter
Fuel filter to fuel pump
Fuel pump to carburetor
Vent tube (Canister to atmosphere)
Impulse line
Vent tube (Carburetor to Canister)
Total (Fuel Line nos. 1 through 5 plus 7):
LENGTH
SOLID COLOR
6.0 in. (15.0 cm)
6.0 in. (15.0 cm)
17.0 in. (44.0 cm) *
24.0 in. (61.0 cm) **
14.0 in. (36.0 cm)
4.7 in. (12.0 cm)
28.0 in. (71.0 cm) *
37.5 in. (95.3 cm) **
71.0 in. (180.3 cm) *
87.5 in. (222.3 cm) **
18
Fuel Pump
CLEAR
12.0 in. (30.5 cm)
12.0 in. (30.5 cm)
Page 18-19