Periodic Service Schedule - Club Car Pioneer 1200 Maintenance Service Manual

PERIODIC MAINTENANCE
• Differential lock cable
In addition, check the items listed below:
• Tires: Visually inspect for wear, damage and proper inflation.
• Exhaust system: Check for leaks.
• Forward/Reverse shifter: Check for proper operation. See Controls and Indicators in the Pioneer
1200 Owner's Manual.
• Fuel system: Check fuel tank, lines, cap, pump, fuel filters, and carburetor for fuel leakage.

PERIODIC SERVICE SCHEDULE

Read DANGER and WARNING on pages 10-1 and 10-2.
∆ WARNING
• Service, repairs, and adjustments must be made per instructions in this maintenance and
service manual.
NOTE: If the vehicle is constantly subjected to heavy use or severe operating conditions, the preventive
maintenance procedures should be performed more often than recommended in the periodic service
and lubrication schedules.
Both the Periodic Service Schedule and the Periodic Lubrication Schedule must be followed to keep
the vehicle in optimum operating condition.
PERIODIC SERVICE SCHEDULE
REGULAR INTERVAL
Monthly service by owner
or trained technician
Semiannual service by
trained technician only
(every 50 hours of
operation)
Periodic Service Schedule continued on next page...
SERVICE
Engine
Tires
General vehicle
Battery
Front wheel alignment and toe-in
Electrical wiring and connections
2001 Pioneer 1200 Gasoline Vehicle Maintenance and Service Manual
Periodic Service Schedule
Check engine oil level; change as required.
See Periodic Lubrication Schedule on
page 10-4.
Check engine cooling air intake; visually inspect
unshrouded area around engine exhaust for
grass and debris, and clean as necessary.
Check air pressure and adjust as necessary
See Section 8 – Wheels and Tires.
Wash engine compartment and underside
of vehicle. Do not wash engine when hot.
Clean terminals and wash dirt from casing;
check electrolyte level.
See Battery, Section 12, Page 12-31.
Check and adjust as required.
See Section 7 – Steering and Front
Suspension.
Check for tightness and damage.
10
Page 10-3